International Journal of Nutrition and Food Sciences

| Peer-Reviewed |

Iron Bioavailability, Storability and Sensory Evaluation of Iron Fortified Extruded Snacks Intended to Alleviate Iron Deficiency in Indian Children

Received: 31 October 2014    Accepted: 16 November 2014    Published: 28 January 2015
Views:       Downloads:

Share This Article

Abstract

Iron deficiency is one of the major health problems in India and is significantly affecting the growth and development of children. The mid day meals offered as an intervention to improve nutritional standards could not fulfill daily iron requirements of children. Iron fortified snack products were developed to supplement these daily meals, by extrusion cooking of nutritional orphan crop finger millet added with fortifying agents NaFeEDTA (sodium iron ethylenediaminetetraacetate) or ferrous fumarate and aonla (Emblica officinalis Gaertn); as a source of ascorbic acid. The extrusion variables were optimized at moisture 18%, barrel temperature 115C, screw speed 260 rpm and addition of cassava at the rate of 30 %, based on the expansion ratio. Iron bioavailability from products was assessed in terms of Haemoglobin Maintenance Efficiency (HME) through Haemoglobin regeneration assay in chicks. Overall HME was significantly different (p < 0.05) for feed fortified with ferrous fumarate (28.66 %), feed fortified with NaFeEDTA (35.26 %), and feed without fortificant (19.15%). Addition of aonla powder to chick feed significantly improved the HME in case of ferrous fumarate whereas, showed no significant effect in the case of NaFeEDTA and feeds without fortificant. Storage stability was evaluated on the basis of density, hardness, and sensory characteristics for both fresh and stored samples. Samples were fried, dusted with spice mix and were packed for storage studies in low-density polyethylene (LDPE) and aluminium foil packaging material, with or without nitrogen flushing. In conclusion, products fortified with NaFeEDTA and packed in aluminium foil with nitrogen flushing were found optimal in terms of iron bioavailability, storability and consumer acceptability.

DOI 10.11648/j.ijnfs.20150401.16
Published in International Journal of Nutrition and Food Sciences (Volume 4, Issue 1, January 2015)
Page(s) 36-44
Creative Commons

This is an Open Access article, distributed under the terms of the Creative Commons Attribution 4.0 International License (http://creativecommons.org/licenses/by/4.0/), which permits unrestricted use, distribution and reproduction in any medium or format, provided the original work is properly cited.

Copyright

Copyright © The Author(s), 2024. Published by Science Publishing Group

Keywords

Malnutrition, Bioavailability, Anaemia, Finger Millet, Fortification, Haemoglobin Regeneration, Chicks

References
[1] Nair KM, Iyengar V. (2009). Iron content, bioavailability & factors affecting iron status of Indians. Indian Journal Medical Research 130(5):634-45.
[2] National Family Health Survey – 3. 2005 – 2006.
[3] Vijayaraghavan K. (2002). Control of micronutrient deficiencies in India: Obstacles and Strategies. Nutr Rev. 60: S73-6.
[4] Varma JL, Das S, Sankar R, Mannar MGV, Levinson FJ, Hamer DH. (2006). Community-level micronutrient fortification of a food supplement in India: a controlled trial in preschool children aged 36-66 months. Am J Clin Nutr 85: 1127–33.
[5] Mid Day Meal Scheme. Nutrition Support Introduction. Retrieved from http://mdm.nic.in/Files/School%20Health%20Programme/Nutrition_Support/Nutrition_support_Introduction.pdf on April 2, 2014
[6] Intecos – CIER, Indiastat. (2012). [online]. Available at: http://www.indiastat.com/table/marketforecast/10143/marketforecastofprocessedfoodinindia20102020/10396/10398/data.aspx. Accessed on 11 June 2012.
[7] Radhakrishan R (2005). Food and nutrition security of the poor. Econ and Polit Weekly 18: 1817–1821.
[8] Desikachar HSR. (1975). Processing of maize, sorghum and millets for food uses. J. Sci. Res. 34: 231-237.
[9] Hallberg L. (1987). Wheat fiber, phytates and iron absorption. Scandinavian Journal of Gastroenterology Supplement. 129: 73-79.
[10] Ramachandra G, Virupaksha TK, Shadaksharaswamy M. (1977). Relationship between tannin levels and in-vitro protein digestibility in finger millet (Eleusine coracana Gaertn). Journal of Agriculture and Food Chemistry, 25(5): 1101–1104.
[11] Udayasekhara Rao P, Deosthale YG. (1988). In vitro availability of iron and zinc in white and coloured ragi (Eleusine coracana): Role of tannin and phytate. Plant Foods Human Nutrition. 38: 35-41.
[12] Watzke HJ. (1998). Impact of processing on bioavailability examples of minerals in foods. Trends Food Sci. Technol. 9: 320-327.
[13] Kaced I, Hoseney RC, Varriano-Marston E. (1984). Factors affecting rancidity in ground pearl millet. Cereal Chem. 61: 187-192.
[14] Nibedita M, Sukumar B. (2003). Extrusion cooking technology employed to reduce the anti-nutritional factor tannin in sesame meal. J. Food. Eng. 56:201-202.
[15] Cisse D, Guiro AT, Diaham B, Souane M, Doumbouya NTS, Wade S. (1998). Effect of food processing on iron availability of African pearl millet weaning foods. Intern. J Food Sci. and Nutr. 49(5): 375-381.
[16] Hurrell RF. (1999). Iron. In: The Mineral Fortification of Foods. Hurrell, R. F. (Eds.). pp. 54–93. Leatherhead Publishing, Surrey, UK.
[17] Hurrell RF, Reddy MB, Burri J, Cook JD. (2000). An evaluation of EDTA compounds for iron fortification of cereal-based foods. Br. J. Nutr. 84(6): 903–910.
[18] Ballot DE, MacPhail AP, Bothwell TH, Gillooly M, Mayet FG. (1989). Fortification of curry powder with NaFe(111)EDTA in an iron deficient population: report of a controlled iron-fortification trial. Am. J. Clin. Nutr. 49(1): 162–169.
[19] Hurrell RF. (2002). Supplement: Forging Effective Strategies to Combat Iron Deficiency: Fortification: Overcoming Technical and Practical Barriers, J. Nutr. 132: 4 806S-812S.
[20] Conrad ME, Schade SG. (1968). Ascorbic acid chelates in iron absorption a role for hydrochloric acid and bile. Gastroenterology. 55(1): 35-45.
[21] Siegenberg D, Baynes RD, Bothwell TH, Mac-farlane BJ, Lamparelli RD, Car NG, MacPhail P , Schmidt U, Tal A and Mayet F .(1991). Ascorbic acid prevents the dose-dependent inhibitory effects of polyphenols and phytates on nonheme-iron absorption. Am Clin. Nutr. 53: 537–541.
[22] Regilda SR, Moreira-Arau ́jo, Arau ́jo Marcos AM, Areˆas Jose ́ AG. (2008). Fortified food made by the extrusion of a mixture of chickpea, corn and bovine lung controls iron-deficiency anaemia in preschool children, Food Chem. 107(1): 158-164.
[23] AOAC. (1990). Bioavailability of iron. Rat Hemoglobin Repletion Bioassay. In: Official Methods of Analysis of the Association of Official Analytical Chemists. 15th. Helrich K, (Ed.) Association of Official Analytical Chemists Inc, Arlington, VA. pp.1098–1099.
[24] Biehl RR, Emmert JL, Baker DH. (1997). Iron bioavailability in soybean meal as affected by supplemental phytase and 1 alpha-hydroxycholecalciferol. Poult. Sci. 76(10): 1424-1427
[25] Boling SD, Edwards HM. (1998). Bioavailability of iron in cottonseed meal, ferric sulfate, and two ferrous sulfate by-products of the galvanizing industry, 3rd, Poult. Sci. 77: 1388-1392.
[26] Fly AD, Gail LC-M. (2000). Iron bioavailability from hemoglobin and hemin in chick, rat, cat, and dog: A comparative study. Nutr Res. 20: 237-248
[27] Pennell MD, Davies MI, Rasper J, Motzok I. (1976). Biological availability of iron supplements for rats chicks and humans. J. Nutr. 106: 265–274.
[28] Shobana S, Malleshi NG.(2003). Preparation and functional properties of decorticated finger millet (Eleusine coracana). J. Food Eng. 79(2) 529-538.
[29] Visvanathan R, Palanisamy PT, Gothandapani L, Sreenarayanan, VV. (1996). Physical properties of neem nut. Journal of Agricultural Engineering Research, 63(1), 19-26.
[30] Chandrasekar V, Viswanathan R. (1999). Physical and thermal properties of coffee. J. Agr. Eng. Res, 73(3), 227-234.
[31] Subramanian S, Viswanathan R. (2007). Bulk density and friction coefficients of selected minor millet grains and flours. Journal of Food Engineering, 81(1), 118-126. doi:http://dx.doi.org/10.1016/j.jfoodeng.2006.09.026
[32] Tako E, Rutzke MA, Glahn RP. (2010). Using domestic chicken (Gallus gallus) as an in vivo model for iron bioavailability. Poultry Sci, 89: 514–521.
[33] Drake JD, Chamblee TN, Schultz CD, Peebles ED, Thaxton JP. (1992). Daily feed and water consumption of broiler chicks from 0 to 21 days of age. J. Appl. Poultry Res. 1: 160-163.
[34] M.R.C.Report. (1943). Brit. Med. J. 1: 209.
[35] Ashford CA. (1943). Observations on the acid haematin method for the estimation of haemoglobin. Brit. Med. J. pp: 575-577.
[36] Tan S., Yeung C, Tako E, Glahn R, Welch R, Lei X, Miller DD .(2008). Iron bioavailability to piglets from red and white beans (Phaseolus vulgaris). J Agr Food Chem. 56:5008– 5014.
[37] Sturkie P. (2000). Avian Physiology. Academic Press, San Diego, CA.
[38] Amerine MA, Pangborn RARoessler EB. (1965). Principles of Sensory Evaluation of Food. Academic Press. New York.
[39] Montgomery DC. (2001). Design and analysis of experiments, fifth ed. Wiley, New York, USA, pp. 455–492.
[40] Rossander-Hulthen L, Gleerup A, Hallberg L. (1990). Inhibitory effect of oat products on non-haem iron absorption in man. Eur J Clin Nutr. 44:783-791.
[41] Tuntawiroon M, Sritongkul N, Brune M, Rossander-Hulten L, Pleehachmda R, Suwanik R, Hallberg L. (1991). .Dose-dependent inhibitory effect of phenolic compounds in foods on nonheme-iron absorption in men. Am. J. Clin. Nutr. 53: 554-557.
[42] Cook JD, Reddy MB, Burri J, Juillerat MA, Hurrell RF. (1997). The influence of different cereal grains on iron absorption from infant cereal foods. Am. J. Clin. Nutr. 65: 964–969.
[43] Lynch SR, Hurrell RF, Bothwell T, MacPhail.(1993). Iron EDTA for Food Fortification. Report of the International Nutritional Anemia Consultative Group (INACG). Washington, DC: ILSI Human Nutrition Institute.
[44] Garcia-Casal MN, Layrisse M, Pena-Rosas JP, Ramirez J, Leets I, Matus P. (2003). Iron absorption from elemental iron-fortified corn flakes in human. Role of vitamin A and C. Nutr Res. 23: 451–463.
[45] MacPhail AP, Patel RC, Bothwell TH, Lamparelli RD. (1994). EDTA and the absorption of iron from food. Am. J. Clin. Nutr. 59: 644–8.
[46] West TS,Sykes AS. (1960). Diamino-ethane-tetra-acetic acid. In: Analytical applications of Diamino-ethane-tetra-acetic acid, pp 9-22 Poole, England The British Drug Houses, Ltd.
[47] Layrisse M, Chaves JF, Mendez-Castellano, Bosch V, Troper E, Bastardo B, González E. (1996). Early response to the effect of iron fortification in the Venezuelan population. Am J of Clin Nutr. 64: 903–907.
[48] Dary O, Freire W, Kim S. (2002). Iron compounds for food fortification guidelines for Latin America and the Caribbean. Nutr Rev. 60: S50-61. Industr. Res. 34: 231-237.
[49] Gowri, BS, Patel K, Prakash J, Srinivasan K. (2001). Influence of amla fruits (Emblica officinalis) on the bioavailability of iron from staple cereals and pulses. Nutrition Research. 21: 1483–1492.
[50] Hallberg L, Rossander L, Skanberg AB. (1987). Phytates and the inhibitory effect of bran on iron absorption in man. Am. J. Clin. Nutr. 45: 988-996.
[51] Hurrell RF, Furniss DE, Burr J, Whittaker P, Lynch SR, Cook JD. (1989). Iron fortification in infant cereals: A proposal for the use of ferrous fumarate or ferrous succinate. Am. J. Clin. Nutr. 49: 1272-1282.
[52] Disler PB, Lynch SR, Charlton RW, Torrance JD, Bothwell TH, Walker RB, Mayet F. (1975). The effect of tea on iron absorption. Gut 16(3): 193-200.
[53] Fidler MC, Davidsson L, Zeder C, Walczyk T, Hurrell RF. (2003). Iron absorption from ferrous fumarate in adult women is influenced by ascorbic acid but not by Na2EDTA. Br. J. Nutr. 90(6): 1081–1085.
[54] Hurrell RF, Reddy MB, Dassenko SA, Cook JD. (1991). Ferrous fumarate fortification of a chocolate drink powder. Brit J of Nutr. 65:271–283.
[55] Zhu Le, Glahn RP, Yeung CK, Miller DD. (2006). Iron Uptake by Caco-2 Cells from NaFeEDTA and FeSO4:  Effects of Ascorbic Acid, pH, and a Fe(II) Chelating Agent. J. Ag Food Chem, 54 (20): 7924-792
[56] Kadam DM, Samuel DVK, Chandra P, Sikarwar HS. (2008). Impact of processing treatments and packaging material on some properties of stored dehydrated cauliflower. Int J Food Sci Tech, 43: 1–14.
[57] Ammawath W, Man YBC, Yusof S, Rahman RA. (2002). Effects of type of packaging material on physicochemical and sensory characteristics of deep-fat-fried banana chips. J. Sci. Food Agric. 82(14): 1621-1627.
[58] Hurrell RF. (1997). Preventing iron deficiency through food fortification. Nutr Rev 55: 210 –22.
Author Information
  • Department of Food and Agricultural Process Engineering, Tamil Nadu Agricultural University, Coimbatore, India

  • Post-Harvest Technology Center, Tamil Nadu Agricultural University, Tamil Nadu, Coimbatore, India

Cite This Article
  • APA Style

    Shashank Gaur, R. Visvanathan. (2015). Iron Bioavailability, Storability and Sensory Evaluation of Iron Fortified Extruded Snacks Intended to Alleviate Iron Deficiency in Indian Children. International Journal of Nutrition and Food Sciences, 4(1), 36-44. https://doi.org/10.11648/j.ijnfs.20150401.16

    Copy | Download

    ACS Style

    Shashank Gaur; R. Visvanathan. Iron Bioavailability, Storability and Sensory Evaluation of Iron Fortified Extruded Snacks Intended to Alleviate Iron Deficiency in Indian Children. Int. J. Nutr. Food Sci. 2015, 4(1), 36-44. doi: 10.11648/j.ijnfs.20150401.16

    Copy | Download

    AMA Style

    Shashank Gaur, R. Visvanathan. Iron Bioavailability, Storability and Sensory Evaluation of Iron Fortified Extruded Snacks Intended to Alleviate Iron Deficiency in Indian Children. Int J Nutr Food Sci. 2015;4(1):36-44. doi: 10.11648/j.ijnfs.20150401.16

    Copy | Download

  • @article{10.11648/j.ijnfs.20150401.16,
      author = {Shashank Gaur and R. Visvanathan},
      title = {Iron Bioavailability, Storability and Sensory Evaluation of Iron Fortified Extruded Snacks Intended to Alleviate Iron Deficiency in Indian Children},
      journal = {International Journal of Nutrition and Food Sciences},
      volume = {4},
      number = {1},
      pages = {36-44},
      doi = {10.11648/j.ijnfs.20150401.16},
      url = {https://doi.org/10.11648/j.ijnfs.20150401.16},
      eprint = {https://download.sciencepg.com/pdf/10.11648.j.ijnfs.20150401.16},
      abstract = {Iron deficiency is one of the major health problems in India and is significantly affecting the growth and development of children. The mid day meals offered as an intervention to improve nutritional standards could not fulfill daily iron requirements of children. Iron fortified snack products were developed to supplement these daily meals, by extrusion cooking of nutritional orphan crop finger millet added with fortifying agents NaFeEDTA (sodium iron ethylenediaminetetraacetate) or ferrous fumarate and aonla (Emblica officinalis Gaertn); as a source of ascorbic acid. The extrusion variables were optimized at moisture 18%, barrel temperature 115C, screw speed 260 rpm and addition of cassava at the rate of 30 %, based on the expansion ratio. Iron bioavailability from products was assessed in terms of Haemoglobin Maintenance Efficiency (HME) through Haemoglobin regeneration assay in chicks. Overall HME was significantly different (p < 0.05) for feed fortified with ferrous fumarate (28.66 %), feed fortified with NaFeEDTA (35.26 %), and feed without fortificant (19.15%). Addition of aonla powder to chick feed significantly improved the HME in case of ferrous fumarate whereas, showed no significant effect in the case of NaFeEDTA and feeds without fortificant. Storage stability was evaluated on the basis of density, hardness, and sensory characteristics for both fresh and stored samples. Samples were fried, dusted with spice mix and were packed for storage studies in low-density polyethylene (LDPE) and aluminium foil packaging material, with or without nitrogen flushing. In conclusion, products fortified with NaFeEDTA and packed in aluminium foil with nitrogen flushing were found optimal in terms of iron bioavailability, storability and consumer acceptability.},
     year = {2015}
    }
    

    Copy | Download

  • TY  - JOUR
    T1  - Iron Bioavailability, Storability and Sensory Evaluation of Iron Fortified Extruded Snacks Intended to Alleviate Iron Deficiency in Indian Children
    AU  - Shashank Gaur
    AU  - R. Visvanathan
    Y1  - 2015/01/28
    PY  - 2015
    N1  - https://doi.org/10.11648/j.ijnfs.20150401.16
    DO  - 10.11648/j.ijnfs.20150401.16
    T2  - International Journal of Nutrition and Food Sciences
    JF  - International Journal of Nutrition and Food Sciences
    JO  - International Journal of Nutrition and Food Sciences
    SP  - 36
    EP  - 44
    PB  - Science Publishing Group
    SN  - 2327-2716
    UR  - https://doi.org/10.11648/j.ijnfs.20150401.16
    AB  - Iron deficiency is one of the major health problems in India and is significantly affecting the growth and development of children. The mid day meals offered as an intervention to improve nutritional standards could not fulfill daily iron requirements of children. Iron fortified snack products were developed to supplement these daily meals, by extrusion cooking of nutritional orphan crop finger millet added with fortifying agents NaFeEDTA (sodium iron ethylenediaminetetraacetate) or ferrous fumarate and aonla (Emblica officinalis Gaertn); as a source of ascorbic acid. The extrusion variables were optimized at moisture 18%, barrel temperature 115C, screw speed 260 rpm and addition of cassava at the rate of 30 %, based on the expansion ratio. Iron bioavailability from products was assessed in terms of Haemoglobin Maintenance Efficiency (HME) through Haemoglobin regeneration assay in chicks. Overall HME was significantly different (p < 0.05) for feed fortified with ferrous fumarate (28.66 %), feed fortified with NaFeEDTA (35.26 %), and feed without fortificant (19.15%). Addition of aonla powder to chick feed significantly improved the HME in case of ferrous fumarate whereas, showed no significant effect in the case of NaFeEDTA and feeds without fortificant. Storage stability was evaluated on the basis of density, hardness, and sensory characteristics for both fresh and stored samples. Samples were fried, dusted with spice mix and were packed for storage studies in low-density polyethylene (LDPE) and aluminium foil packaging material, with or without nitrogen flushing. In conclusion, products fortified with NaFeEDTA and packed in aluminium foil with nitrogen flushing were found optimal in terms of iron bioavailability, storability and consumer acceptability.
    VL  - 4
    IS  - 1
    ER  - 

    Copy | Download

  • Sections