Effects of Whey Protein Concentrate on Shelf Life of Cookies Using Corn and Sunflower Oils

Melina Erben; Hugo Diego Sánchez; Carlos Alberto Osella

doi:doi:10.11648/j.jfns.20140204.25

| Peer-Reviewed |

Effects of Whey Protein Concentrate on Shelf Life of Cookies Using Corn and Sunflower Oils

Melina Erben, Hugo Diego Sánchez, Carlos Alberto Osella

Received: 21 July 2014 Accepted: 9 August 2014 Published: 20 August 2014

Views: Downloads:

Download PDF

Share This Article

Twitter
Linked In
Facebook

Abstract

The objective of this work was to study the effect of whey protein concentrate (WPC) on shelf life of cookies using corn and sunflower oils as fat source. Wheat flour was partially replaced by WPC with levels of 5, 7.5, 10 and 15 %. A User Defined Design was used and the three following responses were measured: peroxide index (meqO2/kg), flavour (score from 1-10) and rancidity (detectable and non-detectable) at 0, 7, 14, 21 and 70 days of storage. Results show that during storage peroxide index (PI) increases in all cookies samples. However a significant decrease was found when corn oil was used instead of sunflower oil and when the level of WPC goes from 0% to 15%. Regarding sensory evaluation, all cookies were evaluated as acceptable (scored flavour ≥ 6) and no rancid flavour was perceived, except for two samples which were assigned with 5 and rancid flavour was considered as detectable; these samples correspond to cookies evaluated at day 70, elaborated with sunflower oil and the lowest dose of WPC. No significant differences were found in cookies flavour prepared with different oils. On the other hand and relative to the level of WPC replacement, differences were found by the panel at days 0 and 7, a reduction in assigned score when WPC dose was increased, however this difference was not significant in the subsequent assessment days. According to research results, an increase in stability was clearly obtained in cookies elaborated with corn oil and the highest concentration of WPC.

DOI	10.11648/j.jfns.20140204.25
Published in	Journal of Food and Nutrition Sciences (Volume 2, Issue 4, July 2014)
Page(s)	195-199
Creative Commons	This is an Open Access article, distributed under the terms of the Creative Commons Attribution 4.0 International License (http://creativecommons.org/licenses/by/4.0/), which permits unrestricted use, distribution and reproduction in any medium or format, provided the original work is properly cited.
Copyright	Copyright © The Author(s), 2024. Published by Science Publishing Group

Keywords

Cookies, Whey Protein Concentrate, Corn Oil, Sunflower Oil

References

[1]	H. D. Sánchez, C. A. Osella, M. A.de la Torre, R. J. González y O. A. Sbodio. “Estudio nutricional relativo a proteínas, energía y calcio en niños que concurren a comedor escolar”. Archivos Latinoamericanos de Nutrición, 1999, 49(3):218-222.
[2]	S. R. Pérez, C. A. Osella, M. A. de la Torre y H. D. Sánchez. “Efecto del mejoramiento proteico sobre los parámetros de calidad nutricional y sensorial de galletitas dulces (cookies). Archivos Latinoamericanos de Nutrición, 2008, 58(4):403-410.
[3]	B. Munaza, S. G. M. Prasad and B. Gayas. “Whey proteins concentrate enriched biscuits”. International Journal of Scientific and Research Publications, 2012, 2(8):1-4.
[4]	H. Korhonen. “Milk-derived bioactive peptides: from science to applications”. Journal of Functional Foods, 2009, 1: 177–187.
[5]	A. N. Visentín, S. R. Drago, C. A. Osella, M. A. de la Torre, H. D. Sánchez y R. J. González. “Efecto de la adición de harina de soja y concentrado proteico de suero de queso sobre la calidad del pan y la dializabilidad de minerales”. Archivos Latinoamericanos de Nutrición, 2009, 59(39):325-331.
[6]	B. Bulut Solak and N. Akin. “Functionality of whey protein”. International Journal of Health & Nutrition, 2012, 3(1):1-7.
[7]	J. Jacob and K. Leelavathi. “Effect of fat-type on cookie dough and cookie quality”. Journal of Food Engineering, 2007, 79(1):299-305.
[8]	E. Muguerza, O. Gimeno, D. Ansorena and I. Astiasaran. “New formulations for healthier dry fermented sausages: a review”. Trends in Food Science and Technology, 2004, 15:452–457.
[9]	A. Valenzuela, J. Sanhueza, S. Nieto, G. Petersen y M. Tavella. “Estudio comparativo en fritura de la estabilidad de diferentes aceites vegetales”. A&G. Aceites y grasas, 2003, 13(4):568-573.
[10]	E. A. Coppin and O. A. Pike. “Oil stability index correlated with sensory determination of oxidative stability in light-exposed soybean oil”. Journal of the American Oil Chemists Society, 2001, 78(1):13-18.
[11]	M. Baldioli, M. Servili, G. Perretti and G. F. Montedoro. “Antioxidant activity of tocopherols and phenolic compounds of virgin olive oil”. Journal of the American Oil Chemists Society, 1996, 73(11):1589-1593.
[12]	A. Kamal-Eldin. “Effect of fatty acids and tocopherols on the oxidative stability of vegetable oils”. European Journal of Lipid Science and Technology, 2006, 108:1051–1061.
[13]	G. O. Adegoke, M. Vijay Kumar, A. G. Gopala Krishna, M. C. Varadraj, K. Sambaiah, and B. R. Lokesh. “Antioxidants and lipid oxidation in foods- a critical appraisal”. Journal of Food Science and Technology, 1998, 35:283–298.
[14]	C. E.Stauffer. “Emulsifier: practical guides for the food industry”. Eagan Press, St Poul, MN, USA, 1999.
[15]	K. Warner and T. Nelsen. “AOCS collaborative study on sensory and volatile compound analyses of vegetable oils”. Journal of the American Oil Chemists Society, 1996, 73:157–165.
[16]	S. Armenta, S. Garrigues and M. de la Guardia. “Determination of edible oil parameters by near infrared spectrometry”. Analytica Chimica Acta, 2007, 596(2):330–337.
[17]	M. D. Mesa García, C. M. Aguilera García y A. Gil Hernández. “Efectos saludables de los lípidos de la dieta”. Alimentación, Nutrición y Salud, 2007, 14(1):12-26.
[18]	C. S. Gaines and C. C. Tsen. “A baking method to evaluate flour quality for rotary molded cookies”. Cereal Chemistry, 1980, 57:429-433.
[19]	AOAC. Association of Official Agricultural Chemists.Official methods of analysis. 15th Edn. Washington, DC. 1990.
[20]	P. I. Zakrys, S. I. Hogan, M. G. O’Sullivan, P. Allenand and J. P. Kerry. “Effects of oxygen concentration on the sensory evaluation and quality indicators of beef muscle packed under modified atmosphere”. Meat Science, 2008, 19:648-655.
[21]	Código Alimentario Argentino (CAA). Capítulo VII. Alimentos grasos aceites alimenticios. Art. 528 y 530.
[22]	C. Alvarado Carrasco y M. Guerra. “Lactosuero como fuente de péptidos bioactivos”. Anales Venezolanos de Nutrición, 2010, 23(1):45-50.
[23]	T. L. McCarthy, J. P. Kerry, J. F. Kerry, P. B. Lynch and D. J. Buckley. “Evaluation of the antioxidant potential of naturalfood/plant extracts as compared with synthetic antioxidants and vitamin E in raw and cooked pork patties”. Meat Science, 2001a, 57:45–52.
[24]	K. Erdmann, B. Cheung and H. Schroder. “The possible roles of food-derived bioactive peptides in reducing the risk of cardiovascular disease”. The Journal of Nutritional Biochemistry, 2008, 19:643-54.

Cite This Article

Plain Text BibTeX RIS

APA Style

Melina Erben, Hugo Diego Sánchez, Carlos Alberto Osella. (2014). Effects of Whey Protein Concentrate on Shelf Life of Cookies Using Corn and Sunflower Oils. Journal of Food and Nutrition Sciences, 2(4), 195-199. https://doi.org/10.11648/j.jfns.20140204.25

Copy | Download

ACS Style

Melina Erben; Hugo Diego Sánchez; Carlos Alberto Osella. Effects of Whey Protein Concentrate on Shelf Life of Cookies Using Corn and Sunflower Oils. J. Food Nutr. Sci. 2014, 2(4), 195-199. doi: 10.11648/j.jfns.20140204.25

Copy | Download

AMA Style

Melina Erben, Hugo Diego Sánchez, Carlos Alberto Osella. Effects of Whey Protein Concentrate on Shelf Life of Cookies Using Corn and Sunflower Oils. J Food Nutr Sci. 2014;2(4):195-199. doi: 10.11648/j.jfns.20140204.25

Copy | Download

@article{10.11648/j.jfns.20140204.25,
  author = {Melina Erben and Hugo Diego Sánchez and Carlos Alberto Osella},
  title = {Effects of Whey Protein Concentrate on Shelf Life of Cookies Using Corn and Sunflower Oils},
  journal = {Journal of Food and Nutrition Sciences},
  volume = {2},
  number = {4},
  pages = {195-199},
  doi = {10.11648/j.jfns.20140204.25},
  url = {https://doi.org/10.11648/j.jfns.20140204.25},
  eprint = {https://article.sciencepublishinggroup.com/pdf/10.11648.j.jfns.20140204.25},
  abstract = {The objective of this work was to study the effect of whey protein concentrate (WPC) on shelf life of cookies using corn and sunflower oils as fat source. Wheat flour was partially replaced by WPC with levels of 5, 7.5, 10 and 15 %. A User Defined Design was used and the three following responses were measured: peroxide index (meqO2/kg), flavour (score from 1-10) and rancidity (detectable and non-detectable) at 0, 7, 14, 21 and 70 days of storage. Results show that during storage peroxide index (PI) increases in all cookies samples. However a significant decrease was found when corn oil was used instead of sunflower oil and when the level of WPC goes from 0% to 15%. Regarding sensory evaluation, all cookies were evaluated as acceptable (scored flavour ≥ 6) and no rancid flavour was perceived, except for two samples which were assigned with 5 and rancid flavour was considered as detectable; these samples correspond to cookies evaluated at day 70, elaborated with sunflower oil and the lowest dose of WPC. No significant differences were found in cookies flavour prepared with different oils. On the other hand and relative to the level of WPC replacement, differences were found by the panel at days 0 and 7, a reduction in assigned score when WPC dose was increased, however this difference was not significant in the subsequent assessment days. According to research results, an increase in stability was clearly obtained in cookies elaborated with corn oil and the highest concentration of WPC.},
 year = {2014}
}

Copy | Download

TY  - JOUR
T1  - Effects of Whey Protein Concentrate on Shelf Life of Cookies Using Corn and Sunflower Oils
AU  - Melina Erben
AU  - Hugo Diego Sánchez
AU  - Carlos Alberto Osella
Y1  - 2014/08/20
PY  - 2014
N1  - https://doi.org/10.11648/j.jfns.20140204.25
DO  - 10.11648/j.jfns.20140204.25
T2  - Journal of Food and Nutrition Sciences
JF  - Journal of Food and Nutrition Sciences
JO  - Journal of Food and Nutrition Sciences
SP  - 195
EP  - 199
PB  - Science Publishing Group
SN  - 2330-7293
UR  - https://doi.org/10.11648/j.jfns.20140204.25
AB  - The objective of this work was to study the effect of whey protein concentrate (WPC) on shelf life of cookies using corn and sunflower oils as fat source. Wheat flour was partially replaced by WPC with levels of 5, 7.5, 10 and 15 %. A User Defined Design was used and the three following responses were measured: peroxide index (meqO2/kg), flavour (score from 1-10) and rancidity (detectable and non-detectable) at 0, 7, 14, 21 and 70 days of storage. Results show that during storage peroxide index (PI) increases in all cookies samples. However a significant decrease was found when corn oil was used instead of sunflower oil and when the level of WPC goes from 0% to 15%. Regarding sensory evaluation, all cookies were evaluated as acceptable (scored flavour ≥ 6) and no rancid flavour was perceived, except for two samples which were assigned with 5 and rancid flavour was considered as detectable; these samples correspond to cookies evaluated at day 70, elaborated with sunflower oil and the lowest dose of WPC. No significant differences were found in cookies flavour prepared with different oils. On the other hand and relative to the level of WPC replacement, differences were found by the panel at days 0 and 7, a reduction in assigned score when WPC dose was increased, however this difference was not significant in the subsequent assessment days. According to research results, an increase in stability was clearly obtained in cookies elaborated with corn oil and the highest concentration of WPC.
VL  - 2
IS  - 4
ER  -

Copy | Download

Author Information

Melina Erben

Instituto de Tecnología de Alimentos, Facultad de Ingeniería Química-Universidad Nacional del Litoral, Santa Fe, Argentina; Consejo Nacional de Investigaciones Científicas y Técnicas (CONICET), Argentina
Hugo Diego Sánchez

Instituto de Tecnología de Alimentos, Facultad de Ingeniería Química-Universidad Nacional del Litoral, Santa Fe, Argentina
Carlos Alberto Osella

Instituto de Tecnología de Alimentos, Facultad de Ingeniería Química-Universidad Nacional del Litoral, Santa Fe, Argentina

Download PDF

Sections

Plain Text BibTeX RIS

APA Style

Melina Erben, Hugo Diego Sánchez, Carlos Alberto Osella. (2014). Effects of Whey Protein Concentrate on Shelf Life of Cookies Using Corn and Sunflower Oils. Journal of Food and Nutrition Sciences, 2(4), 195-199. https://doi.org/10.11648/j.jfns.20140204.25

Copy | Download

ACS Style

Melina Erben; Hugo Diego Sánchez; Carlos Alberto Osella. Effects of Whey Protein Concentrate on Shelf Life of Cookies Using Corn and Sunflower Oils. J. Food Nutr. Sci. 2014, 2(4), 195-199. doi: 10.11648/j.jfns.20140204.25

Copy | Download

AMA Style

Melina Erben, Hugo Diego Sánchez, Carlos Alberto Osella. Effects of Whey Protein Concentrate on Shelf Life of Cookies Using Corn and Sunflower Oils. J Food Nutr Sci. 2014;2(4):195-199. doi: 10.11648/j.jfns.20140204.25

Copy | Download

@article{10.11648/j.jfns.20140204.25,
  author = {Melina Erben and Hugo Diego Sánchez and Carlos Alberto Osella},
  title = {Effects of Whey Protein Concentrate on Shelf Life of Cookies Using Corn and Sunflower Oils},
  journal = {Journal of Food and Nutrition Sciences},
  volume = {2},
  number = {4},
  pages = {195-199},
  doi = {10.11648/j.jfns.20140204.25},
  url = {https://doi.org/10.11648/j.jfns.20140204.25},
  eprint = {https://article.sciencepublishinggroup.com/pdf/10.11648.j.jfns.20140204.25},
  abstract = {The objective of this work was to study the effect of whey protein concentrate (WPC) on shelf life of cookies using corn and sunflower oils as fat source. Wheat flour was partially replaced by WPC with levels of 5, 7.5, 10 and 15 %. A User Defined Design was used and the three following responses were measured: peroxide index (meqO2/kg), flavour (score from 1-10) and rancidity (detectable and non-detectable) at 0, 7, 14, 21 and 70 days of storage. Results show that during storage peroxide index (PI) increases in all cookies samples. However a significant decrease was found when corn oil was used instead of sunflower oil and when the level of WPC goes from 0% to 15%. Regarding sensory evaluation, all cookies were evaluated as acceptable (scored flavour ≥ 6) and no rancid flavour was perceived, except for two samples which were assigned with 5 and rancid flavour was considered as detectable; these samples correspond to cookies evaluated at day 70, elaborated with sunflower oil and the lowest dose of WPC. No significant differences were found in cookies flavour prepared with different oils. On the other hand and relative to the level of WPC replacement, differences were found by the panel at days 0 and 7, a reduction in assigned score when WPC dose was increased, however this difference was not significant in the subsequent assessment days. According to research results, an increase in stability was clearly obtained in cookies elaborated with corn oil and the highest concentration of WPC.},
 year = {2014}
}

Copy | Download

TY  - JOUR
T1  - Effects of Whey Protein Concentrate on Shelf Life of Cookies Using Corn and Sunflower Oils
AU  - Melina Erben
AU  - Hugo Diego Sánchez
AU  - Carlos Alberto Osella
Y1  - 2014/08/20
PY  - 2014
N1  - https://doi.org/10.11648/j.jfns.20140204.25
DO  - 10.11648/j.jfns.20140204.25
T2  - Journal of Food and Nutrition Sciences
JF  - Journal of Food and Nutrition Sciences
JO  - Journal of Food and Nutrition Sciences
SP  - 195
EP  - 199
PB  - Science Publishing Group
SN  - 2330-7293
UR  - https://doi.org/10.11648/j.jfns.20140204.25
AB  - The objective of this work was to study the effect of whey protein concentrate (WPC) on shelf life of cookies using corn and sunflower oils as fat source. Wheat flour was partially replaced by WPC with levels of 5, 7.5, 10 and 15 %. A User Defined Design was used and the three following responses were measured: peroxide index (meqO2/kg), flavour (score from 1-10) and rancidity (detectable and non-detectable) at 0, 7, 14, 21 and 70 days of storage. Results show that during storage peroxide index (PI) increases in all cookies samples. However a significant decrease was found when corn oil was used instead of sunflower oil and when the level of WPC goes from 0% to 15%. Regarding sensory evaluation, all cookies were evaluated as acceptable (scored flavour ≥ 6) and no rancid flavour was perceived, except for two samples which were assigned with 5 and rancid flavour was considered as detectable; these samples correspond to cookies evaluated at day 70, elaborated with sunflower oil and the lowest dose of WPC. No significant differences were found in cookies flavour prepared with different oils. On the other hand and relative to the level of WPC replacement, differences were found by the panel at days 0 and 7, a reduction in assigned score when WPC dose was increased, however this difference was not significant in the subsequent assessment days. According to research results, an increase in stability was clearly obtained in cookies elaborated with corn oil and the highest concentration of WPC.
VL  - 2
IS  - 4
ER  -

Copy | Download