The objective of this work was carried out to study the evaluate air frying process as a new technique for frying process. The Potato strips were fried in both air-frying machines (Tefal Actifry) at 180ºC±5ºC for 40 min and traditional frying process at 180ºC for 40 min, 6 min/batch. After frying, the moisture and oil uptake were determined. Changes in some physico-chemical properties of oil extracted from fried potato strips by the two frying process were determined. Also, organoleptic evaluation of fried potato strips by using air and traditional frying process were evaluated by tasters. Results indicated that the moisture content and oil uptake in fried potato strips by air frying were significantly lower than fried potato strips by traditional frying. Changes in some physico-chemical properties (free fatty acid, peroxide value, polar, polymer and oxidized fatty acids contents) of oil extracted from fried potato were significantly higher in traditional frying than air frying. Organoleptic attributes of fried potato strips by air frying surprised on fried potato strips for traditional frying. Generally, the air frying was more suitable for frying process and produce healthy fried foods than other traditional frying method.
| Published in | Journal of Food and Nutrition Sciences (Volume 2, Issue 4) |
| DOI | 10.11648/j.jfns.20140204.26 |
| Page(s) | 200-206 |
| Creative Commons |
This is an Open Access article, distributed under the terms of the Creative Commons Attribution 4.0 International License (http://creativecommons.org/licenses/by/4.0/), which permits unrestricted use, distribution and reproduction in any medium or format, provided the original work is properly cited. |
| Copyright |
Copyright © The Author(s), 2024. Published by Science Publishing Group |
Air Frying, Polar Compound, Oil Uptake, Moisture Content, Potato Strips
| [1] | Sahin, S., Sastry, S. K. and Bayindirili, L. (1999): Heat transfer during frying of potato slices. J. LWT., 29: 19-24. |
| [2] | Lesinska, G. and Leszczynski, W. (1989): Potato science technology. Elsevier Science, NY. USA. |
| [3] | Hubbard, L. J. and Farkas, B. E. (1999): A method for determining the convective heat transfer coefficient during immersion frying. J. Food Process Eng. 22: 201-214. |
| [4] | Baumann, B. and Escher, E. (1995): Mass and heat transfer during deep fat frying of potato slices. Rate of drying and oil uptake. J. LWT., 28: 395-403. |
| [5] | Moreira, R. G., Sun, X., and Chen, Y. (1997): Factors affecting oil uptake in tortilla chips in deep-fat frying. J Food Eng 31:485–98. |
| [6] | Moreira, R. G., Castell-Perez, M. E., and Barrufet, M. A. (1999a): Fried product processing and characteristics. In: Deep-fat frying: fundamentals and applications. Gaithersburg, Md.: Chapman & Hall Food Science Book. P 11–31. |
| [7] | Choe, E., Kang, W. S., and Chang, Y. S. (1993): Kinds and changes in the amount of flavor compounds formed during storage of the ramyon. Korean J. Food Sci. Technol. 25:52–6. |
| [8] | Moreira, R. G., Castell-Perez, M. E., and Barrufet, M. A. (1999b): Oil absorption in fried foods. In: Deep-fat frying; fundamentals and applications. Gaithersburg, Md.: Chapman & Hall Food Science Book. P 179–221. |
| [9] | Pinthus, E. J., Weinberg, P. and Saguy, I. S. (1993): Criterion for oil uptake during deep – fat frying. J. Food Sci. 58: 204-205. |
| [10] | Garayo, J. and Moreira, R. (2002): Vacuum frying of potato chips, J. Food Eng. 55: 181-191. |
| [11] | Basuny, A. M. M., Shaker, A. M., and Azza, A. A. (2012): Vacuum frying: An alternative to obtain high quality potato chips and fried oil. Global Advanced Research Journal of Food Science and Technology, 1(4):058-065. |
| [12] | Bunger, A., Moyano, P. and Rioseco, V. (2003): NaCl soaking treatment for improving the quality of French-fried potatoes. Food Research Int. 36: 161-166 |
| [13] | Krokida, M. K., Oreopolou, V., Maroulis, Z. B. and Marinos-Kouris, D. (2001): Deep fat frying of potato strips- quality issues. J. Drying Tech. 19: 879-935. |
| [14] | Rubnov, M. and Saguy, I. S. (1997): Fractal analysis and crust water diffusivity of a restructured potato product during deep-fat frying. J. Food Sci. 62: 135-137. |
| [15] | Califano, A. N. and Calvelo, A. (1987): Adjustment of surface concentration of reducing sugars before frying of potato strips. J. Food Proc. and Preser, 12: 1-9. |
| [16] | Krokida, M. K., Oreopolou, V., and Maroulis, Z. B. (2000): Water loss and oil uptake as a function of frying time. Journal of Food Engineering, 44: 39–46. |
| [17] | Mestdagh, F., De Wilde, T., Fraselle, S., Govaert, Y., Ooghe, W. Degroodt, J. M., Verhe, R., Van Peteghem, C. and De Meulenear, B. (2008): Optimization of the blanching process to reduce acrylamide potatoes. LWT-Food Science and Technology, 41(9): 1648-1654. |
| [18] | Clark, J. P. (2003): Happy birthday, potato chips! And other snack development. Food Technology, 12, 1-9. |
| [19] | Saguy, S., and Dana, D. (2003): Integrated approach to deep fat frying engineering, nutrition, health and consumer aspects. Journal of Food Engineering, 56: 143-152. |
| [20] | Troncoso, E., and Oedreschi, F. (2009): Modeling water loss and oil uptake during vacuum frying of pre-treated potato slices. LWT-Food Science and Technology, 42 (6): 116-1173. |
| [21] | Dueik, V., Robert, P. and Bouchon, P. (2010): Vacuum frying reduces oil uptake and improves the quality parameters of carrot crisps. Food Chemistry, 119(3): 1143-1149. |
| [22] | Nagadi, M. O., Wang, Y., Adedeji, A. A. and Raghavan, G. S. V. (2009): Effect of microwave pretreatment on mass transfer during deep-fat frying of chicken nugget. LWT-Food Science and Technology, 42, 439-440. |
| [23] | Moyano, P. C. and Pedrechi, F. (2006): Kinetics of oil uptake during frying of potato slices: effect of pre-treatments. LWT-Food Science and Technology, 39, 285-291. |
| [24] | Debnath, S. Bhat, K. K. and Rastogi, N. K. (2003): Effect of pre-drying on kinetics of moisture loss and oil uptake during deep fat frying of chickpea flour-based snack food. LWT-Food Science and Technology, 36, 91-98. |
| [25] | Oils and Fats International (2013): Prices of selected oils. Oct /Nov. Vol. 29, No. 8, Pp 40. |
| [26] | A.O.A.C. (2005): Association of Official Agriculture Chemists. Official Methods of Analysis of 18th ed., D.C. USA. |
| [27] | Wu, P. F. & Nawar, W. W. (1986): A technique for monitoring his quality of used frying oils. Journal of the American Oil Chemical Society, 63:1363-1367. |
| [28] | Waltking, A. E. and Wessels, H. (1981): Chromatographic separation of polar and non polar components of frying oils. Journal of the Association of Official Analytical Chemistry, 64, 1329-1330. |
| [29] | Gutierrez, F. (1989): Determination de la estabilidade oxidative de acuities de olive virgrnes. Comparacion entre del metodo A. O. M. Y. el metodo Rancimat. Grasas Y Aceities, 40: 1-5. |
| [30] | Carpenter, R. P., Lyon, D. H. and Hasdell, T. A. (2000): Guidelines for Sensory Analysis in Food Product Development and Quality Control. Pp.71-91. Gaithersburg: Aspen Publishers, Inc. |
| [31] | SPSS (2008). SPSS Statistics v. 17.0.1. SPSS Inc., Chicago III. |
| [32] | Ali, A. S., Abdel-Razek, A. G. and Kamil, M. M. (2013): Effect of pre-frying treatments of French fried potatoes to achieve better oil uptake reduction for health and technological aspects. Journal of Applied Sciences Research, 8(10): 5018-5024. |
| [33] | Galoburda, R., Murniece, I. and Karklina, D. (2013): The A3ount of Fat Absorbed by Non-Stored and Stored Potatoes after Frying and Roasting. International Journal of Bioscience, Biochemistry and Bioinformatics, 3 (4): 345-348. |
| [34] | Boskou, G., Salta, F. N., Chiou, A., Troullidou, E., and Andrikopoulos, N. K. (2006): Content of trans, trans-2,4-decadienal in deep-fried and pan-fried potatoes. Eur. J. Lipid Sci. Technol., 108:109–15. |
| [35] | Andres, A., Arguelles, A., Castello, M. L. and Heredia, A. (2013): Mass transfer and volume changes in French fries during air frying. Food Bioprocess Technol., 6: 1917-1924. |
| [36] | Stevenson, S. G., Vaisey-Jenser M and Eskin, N.A.M., 1984. Quality control in the use of deep frying oil. Journal of the American Oil Chemists' Society 61: 1102¬-1108. |
| [37] | Firestone, D., Stier, R. F. and Blumenthal, M. M. (1991): Regulation of frying fats and oils. Food Technol., 45: 90-94. |
| [38] | Yoon, S. H., Jung, M. Y. and Min, D. B. (1988): Effects of thermally oxidized triglycerides on the oxidative stability of soybean oil. J. Am. Oil Chem. Soc., 65(10):1652–6. |
| [39] | Tseng, Y. C., Moreira, R. G. and Sun, X. (1996): Total frying—use time effects on soybean oil deterioration and on tortilla chip quality. Intl. J. Food Sci. Technol., 31:287–94. |
| [40] | Frega,N., Mozzon, M. and Lercker, G. (1999): Effects of Free Fatty Acids on Oxidative Stability of Vegetable Oil. J. Am. Oil Chem. Soc. 76 (3): 325-329. |
| [41] | Gupta M. K. (2005): Bailey’s Industrial Oil and Fat Products, SixthEdition, Six Volume Set. Edited by Fereidoon Shahidi. Copyright # 2005 John Wiley & Sons, Inc. |
APA Style
Shaker, M. Arafat. (2014). Air Frying a New Technique for Produce of Healthy Fried Potato Strips. Journal of Food and Nutrition Sciences, 2(4), 200-206. https://doi.org/10.11648/j.jfns.20140204.26
ACS Style
Shaker; M. Arafat. Air Frying a New Technique for Produce of Healthy Fried Potato Strips. J. Food Nutr. Sci. 2014, 2(4), 200-206. doi: 10.11648/j.jfns.20140204.26
AMA Style
Shaker, M. Arafat. Air Frying a New Technique for Produce of Healthy Fried Potato Strips. J Food Nutr Sci. 2014;2(4):200-206. doi: 10.11648/j.jfns.20140204.26
Share This Article
Twitter
Linked In
Facebook
Copy
Download@article{10.11648/j.jfns.20140204.26,
author = {Shaker and M. Arafat},
title = {Air Frying a New Technique for Produce of Healthy Fried Potato Strips},
journal = {Journal of Food and Nutrition Sciences},
volume = {2},
number = {4},
pages = {200-206},
doi = {10.11648/j.jfns.20140204.26},
url = {https://doi.org/10.11648/j.jfns.20140204.26},
eprint = {https://article.sciencepublishinggroup.com/pdf/10.11648.j.jfns.20140204.26},
abstract = {The objective of this work was carried out to study the evaluate air frying process as a new technique for frying process. The Potato strips were fried in both air-frying machines (Tefal Actifry) at 180ºC±5ºC for 40 min and traditional frying process at 180ºC for 40 min, 6 min/batch. After frying, the moisture and oil uptake were determined. Changes in some physico-chemical properties of oil extracted from fried potato strips by the two frying process were determined. Also, organoleptic evaluation of fried potato strips by using air and traditional frying process were evaluated by tasters. Results indicated that the moisture content and oil uptake in fried potato strips by air frying were significantly lower than fried potato strips by traditional frying. Changes in some physico-chemical properties (free fatty acid, peroxide value, polar, polymer and oxidized fatty acids contents) of oil extracted from fried potato were significantly higher in traditional frying than air frying. Organoleptic attributes of fried potato strips by air frying surprised on fried potato strips for traditional frying. Generally, the air frying was more suitable for frying process and produce healthy fried foods than other traditional frying method.},
year = {2014}
}
TY - JOUR T1 - Air Frying a New Technique for Produce of Healthy Fried Potato Strips AU - Shaker AU - M. Arafat Y1 - 2014/08/20 PY - 2014 N1 - https://doi.org/10.11648/j.jfns.20140204.26 DO - 10.11648/j.jfns.20140204.26 T2 - Journal of Food and Nutrition Sciences JF - Journal of Food and Nutrition Sciences JO - Journal of Food and Nutrition Sciences SP - 200 EP - 206 PB - Science Publishing Group SN - 2330-7293 UR - https://doi.org/10.11648/j.jfns.20140204.26 AB - The objective of this work was carried out to study the evaluate air frying process as a new technique for frying process. The Potato strips were fried in both air-frying machines (Tefal Actifry) at 180ºC±5ºC for 40 min and traditional frying process at 180ºC for 40 min, 6 min/batch. After frying, the moisture and oil uptake were determined. Changes in some physico-chemical properties of oil extracted from fried potato strips by the two frying process were determined. Also, organoleptic evaluation of fried potato strips by using air and traditional frying process were evaluated by tasters. Results indicated that the moisture content and oil uptake in fried potato strips by air frying were significantly lower than fried potato strips by traditional frying. Changes in some physico-chemical properties (free fatty acid, peroxide value, polar, polymer and oxidized fatty acids contents) of oil extracted from fried potato were significantly higher in traditional frying than air frying. Organoleptic attributes of fried potato strips by air frying surprised on fried potato strips for traditional frying. Generally, the air frying was more suitable for frying process and produce healthy fried foods than other traditional frying method. VL - 2 IS - 4 ER -
Information
Email: