Total Environmental Monitoring of a Paper and Pulp Industry in Pakistan

Sana Akhtar; Iqra Tariq; Almas Hamid; Sunaina Ashfaq

doi:doi:10.11648/j.ijema.20130106.16

| Peer-Reviewed

Total Environmental Monitoring of a Paper and Pulp Industry in Pakistan

Sana Akhtar, Iqra Tariq, Almas Hamid, Sunaina Ashfaq

Published in International Journal of Environmental Monitoring and Analysis (Volume 1, Issue 6)

Received: 29 October 2013 Accepted: Published: 30 November 2013

Views: Downloads:

Download PDF

Share This Article

Twitter
Linked In
Facebook

Abstract

The Paper and Paperboard mill selected for environmental monitoring is a large integrated mill, which uses wheat straw, bagasse and waste paper as a raw material for paper production. The plant produces white and brown paper as well as corrugated cartons. A few upset and spills were found at the mill due to old production procedures, however new interventions were made at a few places to fill in the gaps. Material and water balance were drawn for the industry, which showed that the wastewater produced by the mill was 205.6 m3/ton of product. The Suspended Solids (SS) and BOD of the wastewater discharged in the Hudiara drain were found to be 431.8 kg/ton of product and 726 mg/l, respectively. Similarly sulphide content of the wastewater was also exceeding the relevant environmental standards. Among the stack and air emissions studied, all of the parameters were within the prescribed limits of National Environmental Quality Standards (NEQS). The National standards for noise and illumination were also being violated in some areas of the industry, thus depicting poor ergonomic conditions. The cleaner production opportunities were studied for the mill, which concluded that good housekeeping is required and measures for water conservation should be taken in action, which include, repairing the leakages, using pressure nozzles and keeping the taps closed when not in use.

Published in	International Journal of Environmental Monitoring and Analysis (Volume 1, Issue 6)
DOI	10.11648/j.ijema.20130106.16
Page(s)	307-314
Creative Commons	This is an Open Access article, distributed under the terms of the Creative Commons Attribution 4.0 International License (http://creativecommons.org/licenses/by/4.0/), which permits unrestricted use, distribution and reproduction in any medium or format, provided the original work is properly cited.
Copyright	Copyright © The Author(s), 2024. Published by Science Publishing Group

Keywords

Paper and Board Industry, Material Balance, BOD, Noise and Illumination, NEQS, House Keeping

References

[1]	PCSIR, Problems and Solutions, Pakistan Council of Scientific and Industrial Research, Karachi, 2004.
[2]	S.S Ahmad and M.Sohaib, "Report on Paper and Board Industry of Pakistan, SPA, University of Management Technologies," 2010.
[3]	ECC (Environment and Conservation Council), Toward Sustainability-Achieving Cleaner Production in Australia, Australia and New Zealand, 16thMeeting, Hobart, Tasmania,1998.
[4]	CIPEC, "Benchmarking energy use in Canadian pulp and paper mills. Eco-energy, an eco-action initiative,Natural resources," Canada, 2008.
[5]	TV Anh, "Cleaner Production Audit of Pulp and Paper Industry: A Case Study in Vietnam," Asian Institute of Technology, Bangkok, Thailand, 1996.
[6]	NPC (National Productivity Council), "Development of guidelines for water conservation in pulp and paper sector," New Delhi, 2006.
[7]	World Bank, Pulp and Paper Mills, Pollution Prevention and Abatement Handbook, World Bank Group, 1998.

Cite This Article

Plain Text BibTeX RIS

APA Style

Sana Akhtar, Iqra Tariq, Almas Hamid, Sunaina Ashfaq. (2013). Total Environmental Monitoring of a Paper and Pulp Industry in Pakistan. International Journal of Environmental Monitoring and Analysis, 1(6), 307-314. https://doi.org/10.11648/j.ijema.20130106.16

Copy | Download

ACS Style

Sana Akhtar; Iqra Tariq; Almas Hamid; Sunaina Ashfaq. Total Environmental Monitoring of a Paper and Pulp Industry in Pakistan. Int. J. Environ. Monit. Anal. 2013, 1(6), 307-314. doi: 10.11648/j.ijema.20130106.16

Copy | Download

AMA Style

Sana Akhtar, Iqra Tariq, Almas Hamid, Sunaina Ashfaq. Total Environmental Monitoring of a Paper and Pulp Industry in Pakistan. Int J Environ Monit Anal. 2013;1(6):307-314. doi: 10.11648/j.ijema.20130106.16

Copy | Download

@article{10.11648/j.ijema.20130106.16,
  author = {Sana Akhtar and Iqra Tariq and Almas Hamid and Sunaina Ashfaq},
  title = {Total Environmental Monitoring of a Paper and Pulp Industry in Pakistan},
  journal = {International Journal of Environmental Monitoring and Analysis},
  volume = {1},
  number = {6},
  pages = {307-314},
  doi = {10.11648/j.ijema.20130106.16},
  url = {https://doi.org/10.11648/j.ijema.20130106.16},
  eprint = {https://article.sciencepublishinggroup.com/pdf/10.11648.j.ijema.20130106.16},
  abstract = {The Paper and Paperboard mill selected for environmental monitoring is a large integrated mill, which uses wheat straw, bagasse and waste paper as a raw material for paper production. The plant produces white and brown paper as well as corrugated cartons. A few upset and spills were found at the mill due to old production procedures, however new interventions were made at a few places to fill in the gaps. Material and water balance were drawn for the industry, which showed that the wastewater produced by the mill was 205.6 m3/ton of product. The Suspended Solids (SS) and BOD of the wastewater discharged in the Hudiara drain were found to be 431.8 kg/ton of product and 726 mg/l, respectively. Similarly sulphide content of the wastewater was also exceeding the relevant environmental standards. Among the stack and air emissions studied, all of the parameters were within the prescribed limits of National Environmental Quality Standards (NEQS). The National standards for noise and illumination were also being violated in some areas of the industry, thus depicting poor ergonomic conditions. The cleaner production opportunities were studied for the mill, which concluded that good housekeeping is required and measures for water conservation should be taken in action, which include, repairing the leakages, using pressure nozzles and keeping the taps closed when not in use.},
 year = {2013}
}

Copy | Download

TY  - JOUR
T1  - Total Environmental Monitoring of a Paper and Pulp Industry in Pakistan
AU  - Sana Akhtar
AU  - Iqra Tariq
AU  - Almas Hamid
AU  - Sunaina Ashfaq
Y1  - 2013/11/30
PY  - 2013
N1  - https://doi.org/10.11648/j.ijema.20130106.16
DO  - 10.11648/j.ijema.20130106.16
T2  - International Journal of Environmental Monitoring and Analysis
JF  - International Journal of Environmental Monitoring and Analysis
JO  - International Journal of Environmental Monitoring and Analysis
SP  - 307
EP  - 314
PB  - Science Publishing Group
SN  - 2328-7667
UR  - https://doi.org/10.11648/j.ijema.20130106.16
AB  - The Paper and Paperboard mill selected for environmental monitoring is a large integrated mill, which uses wheat straw, bagasse and waste paper as a raw material for paper production. The plant produces white and brown paper as well as corrugated cartons. A few upset and spills were found at the mill due to old production procedures, however new interventions were made at a few places to fill in the gaps. Material and water balance were drawn for the industry, which showed that the wastewater produced by the mill was 205.6 m3/ton of product. The Suspended Solids (SS) and BOD of the wastewater discharged in the Hudiara drain were found to be 431.8 kg/ton of product and 726 mg/l, respectively. Similarly sulphide content of the wastewater was also exceeding the relevant environmental standards. Among the stack and air emissions studied, all of the parameters were within the prescribed limits of National Environmental Quality Standards (NEQS). The National standards for noise and illumination were also being violated in some areas of the industry, thus depicting poor ergonomic conditions. The cleaner production opportunities were studied for the mill, which concluded that good housekeeping is required and measures for water conservation should be taken in action, which include, repairing the leakages, using pressure nozzles and keeping the taps closed when not in use.
VL  - 1
IS  - 6
ER  -

Copy | Download

Author Information

Sana Akhtar

Kinnaird College for Women, Lahore, Pakistan
Iqra Tariq

Kinnaird College for Women, Lahore, Pakistan
Almas Hamid

Kinnaird College for Women, Lahore, Pakistan
Sunaina Ashfaq

Kinnaird College for Women, Lahore, Pakistan

Download PDF

Sections

Plain Text BibTeX RIS

APA Style

Sana Akhtar, Iqra Tariq, Almas Hamid, Sunaina Ashfaq. (2013). Total Environmental Monitoring of a Paper and Pulp Industry in Pakistan. International Journal of Environmental Monitoring and Analysis, 1(6), 307-314. https://doi.org/10.11648/j.ijema.20130106.16

Copy | Download

ACS Style

Sana Akhtar; Iqra Tariq; Almas Hamid; Sunaina Ashfaq. Total Environmental Monitoring of a Paper and Pulp Industry in Pakistan. Int. J. Environ. Monit. Anal. 2013, 1(6), 307-314. doi: 10.11648/j.ijema.20130106.16

Copy | Download

AMA Style

Sana Akhtar, Iqra Tariq, Almas Hamid, Sunaina Ashfaq. Total Environmental Monitoring of a Paper and Pulp Industry in Pakistan. Int J Environ Monit Anal. 2013;1(6):307-314. doi: 10.11648/j.ijema.20130106.16

Copy | Download

@article{10.11648/j.ijema.20130106.16,
  author = {Sana Akhtar and Iqra Tariq and Almas Hamid and Sunaina Ashfaq},
  title = {Total Environmental Monitoring of a Paper and Pulp Industry in Pakistan},
  journal = {International Journal of Environmental Monitoring and Analysis},
  volume = {1},
  number = {6},
  pages = {307-314},
  doi = {10.11648/j.ijema.20130106.16},
  url = {https://doi.org/10.11648/j.ijema.20130106.16},
  eprint = {https://article.sciencepublishinggroup.com/pdf/10.11648.j.ijema.20130106.16},
  abstract = {The Paper and Paperboard mill selected for environmental monitoring is a large integrated mill, which uses wheat straw, bagasse and waste paper as a raw material for paper production. The plant produces white and brown paper as well as corrugated cartons. A few upset and spills were found at the mill due to old production procedures, however new interventions were made at a few places to fill in the gaps. Material and water balance were drawn for the industry, which showed that the wastewater produced by the mill was 205.6 m3/ton of product. The Suspended Solids (SS) and BOD of the wastewater discharged in the Hudiara drain were found to be 431.8 kg/ton of product and 726 mg/l, respectively. Similarly sulphide content of the wastewater was also exceeding the relevant environmental standards. Among the stack and air emissions studied, all of the parameters were within the prescribed limits of National Environmental Quality Standards (NEQS). The National standards for noise and illumination were also being violated in some areas of the industry, thus depicting poor ergonomic conditions. The cleaner production opportunities were studied for the mill, which concluded that good housekeeping is required and measures for water conservation should be taken in action, which include, repairing the leakages, using pressure nozzles and keeping the taps closed when not in use.},
 year = {2013}
}

Copy | Download

TY  - JOUR
T1  - Total Environmental Monitoring of a Paper and Pulp Industry in Pakistan
AU  - Sana Akhtar
AU  - Iqra Tariq
AU  - Almas Hamid
AU  - Sunaina Ashfaq
Y1  - 2013/11/30
PY  - 2013
N1  - https://doi.org/10.11648/j.ijema.20130106.16
DO  - 10.11648/j.ijema.20130106.16
T2  - International Journal of Environmental Monitoring and Analysis
JF  - International Journal of Environmental Monitoring and Analysis
JO  - International Journal of Environmental Monitoring and Analysis
SP  - 307
EP  - 314
PB  - Science Publishing Group
SN  - 2328-7667
UR  - https://doi.org/10.11648/j.ijema.20130106.16
AB  - The Paper and Paperboard mill selected for environmental monitoring is a large integrated mill, which uses wheat straw, bagasse and waste paper as a raw material for paper production. The plant produces white and brown paper as well as corrugated cartons. A few upset and spills were found at the mill due to old production procedures, however new interventions were made at a few places to fill in the gaps. Material and water balance were drawn for the industry, which showed that the wastewater produced by the mill was 205.6 m3/ton of product. The Suspended Solids (SS) and BOD of the wastewater discharged in the Hudiara drain were found to be 431.8 kg/ton of product and 726 mg/l, respectively. Similarly sulphide content of the wastewater was also exceeding the relevant environmental standards. Among the stack and air emissions studied, all of the parameters were within the prescribed limits of National Environmental Quality Standards (NEQS). The National standards for noise and illumination were also being violated in some areas of the industry, thus depicting poor ergonomic conditions. The cleaner production opportunities were studied for the mill, which concluded that good housekeeping is required and measures for water conservation should be taken in action, which include, repairing the leakages, using pressure nozzles and keeping the taps closed when not in use.
VL  - 1
IS  - 6
ER  -

Copy | Download