Biodiesel, HSD, and JP-8 Combustion Process and Emission Characteristics in a Dual-Stage Fuel Injection Condition

Hyungmin Lee

doi:doi:10.11648/j.ijepe.20140304.15

| Peer-Reviewed

Biodiesel, HSD, and JP-8 Combustion Process and Emission Characteristics in a Dual-Stage Fuel Injection Condition

Hyungmin Lee

Published in International Journal of Energy and Power Engineering (Volume 3, Issue 4)

Received: 18 August 2014 Accepted: 1 September 2014 Published: 20 September 2014

Views: Downloads:

Download PDF

Share This Article

Twitter
Linked In
Facebook

Abstract

This research was focused on an investigation of the effect of injection dwell time in a dual-stage injection on the combustion and emission characteristics of biodiesel using an optically accessible single-piston diesel engine. In addition, the results from biodiesel combustion and emission characteristics were compared to those of fossil fuels such as HSD and JP-8 using combustion process visualization as well as emission analyzer. Regarding combustion characteristics, JP-8 showed the highest peak in-cylinder pressure and rate of heat release in comparison to biodiesel and HSD because the higher lower heating value and vaporization characteristics of JP-8 improved premixed combustion. However, the IMEP of JP-8 was lower than the corresponding pressure of HSD. From the viewpoint of emissions, biodiesel had reduced emissions of NOx, HC, CO, and CO2 compared to fossil fuels regardless of the injection dwell time. The natural luminosity combustion images indicated that the biodiesel fuel had a shorter ignition delay, and the combustion progress of JP-8 was accelerated due to superior vaporization, although the initial combustion was slightly delayed in the second injection phase compared to biodiesel and HSD.

Published in	International Journal of Energy and Power Engineering (Volume 3, Issue 4)
DOI	10.11648/j.ijepe.20140304.15
Page(s)	209-216
Creative Commons	This is an Open Access article, distributed under the terms of the Creative Commons Attribution 4.0 International License (http://creativecommons.org/licenses/by/4.0/), which permits unrestricted use, distribution and reproduction in any medium or format, provided the original work is properly cited.
Copyright	Copyright © The Author(s), 2024. Published by Science Publishing Group

Keywords

Injection Dwell Time, Dual Stage Injection, Biodiesel, HSD, JP-8

References

[1]	S.H. Park, I.M. Youn, and C.S. Lee, “Influence of two-stage injection and exhaust gas recirculation on the emissions reduction in an ethanol-blended diesel-fueled four-cylinder diesel engine,” Fuel Process. Technol. vol. 91, pp. 1753-1760, 2010.
[2]	H.M. Lee, “Fuel-based estimation of exhaust emissions from a medium speed propulsive diesel engine for a naval vessel under ocean going conditions,” Nav. Eng. J. vol. 125, No. 4, pp. 113-118, 2013.
[3]	H.M. Lee, and Y.H. Jung, “The effect of dynamic operating conditions on nano-particle emissions from a light-duty diesel engine applicable to prime and auxiliary machines on marine vessel,” Int. J. Nav. Archit. Ocean. Eng. Vol. 4, pp. 403-411, 2013.
[4]	P.K. Sahoo, L.M. Das, M.K.G. Babu, P. Arora, V.P. Singh, and N.R. Kumar, “Comparative evaluation of performance and emission characteristics of jatropha, karanja and polanga based biodiesel as fuel in a tractor engine,” Fuel, vol. 88 pp. 1698-1707, 2008.
[5]	G. Fontaras, G. Karavalakis, M. Kousoulidou, T. Tzamkiozis, L. Ntziachristos, and E. Bakeas, “Effects of biodiesel on passenger car fuel consumption, regulated and non-regulated pollutant emissions over legislated and real-world driving cycles,” Fuel, vol. 88, pp. 1608-1617, 2009.
[6]	J.P. Szybist, J. Song, M. Alam, and A.L. Boehman, “Biodiesel combustion, emissions and emission control,” Fuel Process. Technol. vol. 88, pp. 679-691, 2007.
[7]	S. Murillo, J.L. Mıguez, J. Porteiro, E. Granada, and J.C. Moran, “Performance and exhaust emissions in the use of biodiesel in outboard diesel engines,” Fuel, vol. 86, pp. 1765-1771, 2007.
[8]	J. Xue, T.E. Grift, and A.C. Hansen, “Effect of biodiesel on engine performance and emissions,” Renewable and Sustainable Energy Rev. vol. 15, pp. 1098-1116, 2011.
[9]	G. Fernades, J. Fuschetto, Z. Filipi, D. Assanis, and H. Mckee, “Impact of military JP-8 fuel on heavy- duty diesel engine performance and emissions,” Proc. Inst. Mech. Engrs. Part D: J. Automot. Eng. vol. 221, pp. 957-970, 2007.
[10]	D. Korres, E. Lois, and D. Karnois, “Use of JP-8 aviation fuel and biodiesel on a diesel engine,” SAE Technical Paper 2004-01-3033, 2004.
[11]	J.W. Lee, H.C. Oh, and C.S. Bae, “Combustion process of JP-8 and fossil diesel fuel in a heavy duty diesel engine using two-color thermometry,” Fuel, vol. 102, pp. 264-273,2012.
[12]	C. Jayakumar, J. Nargunde, A. Sinha, N.A. Henein, and E. Sattler, “Effect of biodiesel, jet propellant (JP-8) and ultra low sulfur diesel fuel on auto-ignition, combustion, performance and emissions in a single cylinder diesel engine,” J. Eng. Gas Turbines Power, vol. 134, pp. 1-11, 2012.
[13]	J.B. Heywood, Internal Combustion Engine Fundamentals, McGraw-Hill, New York, 1988.
[14]	J.S. Hwang, D. Qi, Y.J Jung, and C.S Bae, “Effect of injection parameters on the combustion and emissions characteristics in a common-rail direct injection diesel engine fueled with waste cooking oil biodiesel,” Renewable Energy, vol. 63 pp. 9-17, 2014.
[15]	B. Kegl, and A. Heribernik, “Experimental analysis of injection characteristics using biodiesel fuel,” Energy and Fuels, vol. 20, pp. 2239-2248, 2006.
[16]	S.H. Park, S.H. Yoon, and C.S. Lee, “Effects of multiple-injection strategies on overall spray behavior, combustion, and emissions reduction characteristics of biodiesel fuel,” Appl. Energy, vol. 88, pp. 88-98, 2011.
[17]	J.W. Lee, and C.S. Bae, “Apllication of JP-8 in a heavy duty diesel engine,” Fuel, vol. 90, pp. 1762-1770, 2011.
[18]	J. Jang, and C.S. Bae, “Effects of valve events on the engine efficiency in a homogeneous charge compression ignition engine fueled by dimethyl ether,” Fuel, vol. 88, pp. 1228-1234, 2009.
[19]	K. Verbiezen, A.J. Donkerbroek, R.J.H. Klein-Douwel, A.P. van Vliet, P.J.M. Frijters, X.L.J. Seykens, R.S.G. Baert, W.L. Meerts, N.J. Dam, and J.J. ter Meulen, “Diesel combustion: In-cylinder NO concentrations in relation to injection timing,” Combus. Flame, vol. 151, pp. 333-346, 2007.
[20]	D. leung, Y. Luo, and T. Chan, “Optimization of exhaust emissions of a diesel engine fuelled with biodiesel/diesel blends, Energy and Fuels,” vol. 20, pp. 1015-1023, 2006.
[21]	G.R. Kannan, and R. Anand, “Experimental evaluation of DI diesel engine operating with diestrol at varing injection pressure and injection timing,” Fuel Process. Technol. vol. 92, pp. 2252-2263, 2011.
[22]	J. Jeon, J.T. Lee, Y.S. Lim, S.I. Kwon, Y.H. Park, J. Cha, K. Lee, and S. Park, “Flame temperature distributions of biodiesel fuel in a single-cylinder diesel engine,” Fuel Process Technol. vol. 110, pp. 227-234, 2013.
[23]	D.H. Qi, H. Chen, L. Chen, Y. Bian, and Z. Bian, “Experimental studies on the combustion characteristics and performance of a direct injection engine fueled with biodiesel/diesel blends,” Energy Convers. Manage. vol. 50, pp. 2985-2992, 2010.
[24]	H. Aydin, and C. İIkılıç, “Effect of ethanol blending with biodiesel on engine performance and exhaust emissions in a CI engine,” Appl. Therm. Eng. vol. 30, pp. 1199-1204, 2010.
[25]	M. Karabektas, “The effects of turbocharger on the performance and exhaust emissions of a diesel engine fuelled with biodiesel,” Renewable Energy, vol. 34, pp. 989-993, 2009.
[26]	Z. Utlu, and M.S. Koçak, “The effect of biodiesel fuel obtained from waste frying oil on direct injection diesel engine performance and exhaust emissions,” Renewable Energy, vol. 33, pp. 1936-1941, 2008.
[27]	J. Pan, W. Yang, S. Chou, D. Li, H. Xue, J. Zhao, and A. Tang, “Spray and combustion visualization of biodiesel in a direct injection diesel engine,” Therm. Sci. vol. 17, pp. 279-289, 2013.
[28]	L.M. Pickett, and L. Hoogterp, “Fundamental spray and combustion measurement of JP-8 at diesel conditions,” SAE Technical Paper 2008-01-1083, 2008.

Cite This Article

Plain Text BibTeX RIS

APA Style

Hyungmin Lee. (2014). Biodiesel, HSD, and JP-8 Combustion Process and Emission Characteristics in a Dual-Stage Fuel Injection Condition. International Journal of Energy and Power Engineering, 3(4), 209-216. https://doi.org/10.11648/j.ijepe.20140304.15

Copy | Download

ACS Style

Hyungmin Lee. Biodiesel, HSD, and JP-8 Combustion Process and Emission Characteristics in a Dual-Stage Fuel Injection Condition. Int. J. Energy Power Eng. 2014, 3(4), 209-216. doi: 10.11648/j.ijepe.20140304.15

Copy | Download

AMA Style

Hyungmin Lee. Biodiesel, HSD, and JP-8 Combustion Process and Emission Characteristics in a Dual-Stage Fuel Injection Condition. Int J Energy Power Eng. 2014;3(4):209-216. doi: 10.11648/j.ijepe.20140304.15

Copy | Download

@article{10.11648/j.ijepe.20140304.15,
  author = {Hyungmin Lee},
  title = {Biodiesel, HSD, and JP-8 Combustion Process and Emission Characteristics in a Dual-Stage Fuel Injection Condition},
  journal = {International Journal of Energy and Power Engineering},
  volume = {3},
  number = {4},
  pages = {209-216},
  doi = {10.11648/j.ijepe.20140304.15},
  url = {https://doi.org/10.11648/j.ijepe.20140304.15},
  eprint = {https://article.sciencepublishinggroup.com/pdf/10.11648.j.ijepe.20140304.15},
  abstract = {This research was focused on an investigation of the effect of injection dwell time in a dual-stage injection on the combustion and emission characteristics of biodiesel using an optically accessible single-piston diesel engine. In addition, the results from biodiesel combustion and emission characteristics were compared to those of fossil fuels such as HSD and JP-8 using combustion process visualization as well as emission analyzer. Regarding combustion characteristics, JP-8 showed the highest peak in-cylinder pressure and rate of heat release in comparison to biodiesel and HSD because the higher lower heating value and vaporization characteristics of JP-8 improved premixed combustion. However, the IMEP of JP-8 was lower than the corresponding pressure of HSD. From the viewpoint of emissions, biodiesel had reduced emissions of NOx, HC, CO, and CO2 compared to fossil fuels regardless of the injection dwell time. The natural luminosity combustion images indicated that the biodiesel fuel had a shorter ignition delay, and the combustion progress of JP-8 was accelerated due to superior vaporization, although the initial combustion was slightly delayed in the second injection phase compared to biodiesel and HSD.},
 year = {2014}
}

Copy | Download

TY  - JOUR
T1  - Biodiesel, HSD, and JP-8 Combustion Process and Emission Characteristics in a Dual-Stage Fuel Injection Condition
AU  - Hyungmin Lee
Y1  - 2014/09/20
PY  - 2014
N1  - https://doi.org/10.11648/j.ijepe.20140304.15
DO  - 10.11648/j.ijepe.20140304.15
T2  - International Journal of Energy and Power Engineering
JF  - International Journal of Energy and Power Engineering
JO  - International Journal of Energy and Power Engineering
SP  - 209
EP  - 216
PB  - Science Publishing Group
SN  - 2326-960X
UR  - https://doi.org/10.11648/j.ijepe.20140304.15
AB  - This research was focused on an investigation of the effect of injection dwell time in a dual-stage injection on the combustion and emission characteristics of biodiesel using an optically accessible single-piston diesel engine. In addition, the results from biodiesel combustion and emission characteristics were compared to those of fossil fuels such as HSD and JP-8 using combustion process visualization as well as emission analyzer. Regarding combustion characteristics, JP-8 showed the highest peak in-cylinder pressure and rate of heat release in comparison to biodiesel and HSD because the higher lower heating value and vaporization characteristics of JP-8 improved premixed combustion. However, the IMEP of JP-8 was lower than the corresponding pressure of HSD. From the viewpoint of emissions, biodiesel had reduced emissions of NOx, HC, CO, and CO2 compared to fossil fuels regardless of the injection dwell time. The natural luminosity combustion images indicated that the biodiesel fuel had a shorter ignition delay, and the combustion progress of JP-8 was accelerated due to superior vaporization, although the initial combustion was slightly delayed in the second injection phase compared to biodiesel and HSD.
VL  - 3
IS  - 4
ER  -

Copy | Download

Author Information

Hyungmin Lee

Department of Naval Ship Propulsion System Engineering, Republic of Korea Naval Academy, Jinhaegu, Changwonsi, Gyeongsangnamdo, Korea

Download PDF

Sections

Plain Text BibTeX RIS

APA Style

Hyungmin Lee. (2014). Biodiesel, HSD, and JP-8 Combustion Process and Emission Characteristics in a Dual-Stage Fuel Injection Condition. International Journal of Energy and Power Engineering, 3(4), 209-216. https://doi.org/10.11648/j.ijepe.20140304.15

Copy | Download

ACS Style

Hyungmin Lee. Biodiesel, HSD, and JP-8 Combustion Process and Emission Characteristics in a Dual-Stage Fuel Injection Condition. Int. J. Energy Power Eng. 2014, 3(4), 209-216. doi: 10.11648/j.ijepe.20140304.15

Copy | Download

AMA Style

Hyungmin Lee. Biodiesel, HSD, and JP-8 Combustion Process and Emission Characteristics in a Dual-Stage Fuel Injection Condition. Int J Energy Power Eng. 2014;3(4):209-216. doi: 10.11648/j.ijepe.20140304.15

Copy | Download

@article{10.11648/j.ijepe.20140304.15,
  author = {Hyungmin Lee},
  title = {Biodiesel, HSD, and JP-8 Combustion Process and Emission Characteristics in a Dual-Stage Fuel Injection Condition},
  journal = {International Journal of Energy and Power Engineering},
  volume = {3},
  number = {4},
  pages = {209-216},
  doi = {10.11648/j.ijepe.20140304.15},
  url = {https://doi.org/10.11648/j.ijepe.20140304.15},
  eprint = {https://article.sciencepublishinggroup.com/pdf/10.11648.j.ijepe.20140304.15},
  abstract = {This research was focused on an investigation of the effect of injection dwell time in a dual-stage injection on the combustion and emission characteristics of biodiesel using an optically accessible single-piston diesel engine. In addition, the results from biodiesel combustion and emission characteristics were compared to those of fossil fuels such as HSD and JP-8 using combustion process visualization as well as emission analyzer. Regarding combustion characteristics, JP-8 showed the highest peak in-cylinder pressure and rate of heat release in comparison to biodiesel and HSD because the higher lower heating value and vaporization characteristics of JP-8 improved premixed combustion. However, the IMEP of JP-8 was lower than the corresponding pressure of HSD. From the viewpoint of emissions, biodiesel had reduced emissions of NOx, HC, CO, and CO2 compared to fossil fuels regardless of the injection dwell time. The natural luminosity combustion images indicated that the biodiesel fuel had a shorter ignition delay, and the combustion progress of JP-8 was accelerated due to superior vaporization, although the initial combustion was slightly delayed in the second injection phase compared to biodiesel and HSD.},
 year = {2014}
}

Copy | Download

TY  - JOUR
T1  - Biodiesel, HSD, and JP-8 Combustion Process and Emission Characteristics in a Dual-Stage Fuel Injection Condition
AU  - Hyungmin Lee
Y1  - 2014/09/20
PY  - 2014
N1  - https://doi.org/10.11648/j.ijepe.20140304.15
DO  - 10.11648/j.ijepe.20140304.15
T2  - International Journal of Energy and Power Engineering
JF  - International Journal of Energy and Power Engineering
JO  - International Journal of Energy and Power Engineering
SP  - 209
EP  - 216
PB  - Science Publishing Group
SN  - 2326-960X
UR  - https://doi.org/10.11648/j.ijepe.20140304.15
AB  - This research was focused on an investigation of the effect of injection dwell time in a dual-stage injection on the combustion and emission characteristics of biodiesel using an optically accessible single-piston diesel engine. In addition, the results from biodiesel combustion and emission characteristics were compared to those of fossil fuels such as HSD and JP-8 using combustion process visualization as well as emission analyzer. Regarding combustion characteristics, JP-8 showed the highest peak in-cylinder pressure and rate of heat release in comparison to biodiesel and HSD because the higher lower heating value and vaporization characteristics of JP-8 improved premixed combustion. However, the IMEP of JP-8 was lower than the corresponding pressure of HSD. From the viewpoint of emissions, biodiesel had reduced emissions of NOx, HC, CO, and CO2 compared to fossil fuels regardless of the injection dwell time. The natural luminosity combustion images indicated that the biodiesel fuel had a shorter ignition delay, and the combustion progress of JP-8 was accelerated due to superior vaporization, although the initial combustion was slightly delayed in the second injection phase compared to biodiesel and HSD.
VL  - 3
IS  - 4
ER  -

Copy | Download