American Journal of Energy Engineering
Volume 1, Issue 2, May 2013, Pages: 22-29
Received: Apr. 23, 2013;
Published: May 2, 2013
Views 3244 Downloads 864
Assefa Alena, Department of Chemical Engineering, Wollo University, Kombolcha, South Wollo Ethiopia
Omprakash Sahu, Department of Chemical Engineering, Wollo University, Kombolcha, South Wollo Ethiopia
During sugar production, bagasse (waste) is produced which is used as energy resource in the sugar mill. Co-generation power plants using bagasse as the feedstock are attached to several sugar factories in Thailand. These produce steam and electricity for use in the sugar mills and also sell the excess power to the grid. Bagasse, being a by-product of sugar production as well as of biomass origin seems to be a suitable candidate for sustainable energy production. However the case is quite different in Shoa Sugar Factory, which suffers from lack of bagasse during stoppage of mill and as a matter of fact it is forced to cut trees of the surrounding to deliver it to its boilers during stoppage of mill. It is a crystal clear fact that cutting trees without replacement causes the desertification, which is currently the case in Shoa Sugar Factory. It is from this fact that the objectives of the research work emanate. The first part of the study deals with bagasse and its properties, this part of the study focuses on determining the quality and quantity of bagasse that has been used by the factory as a fuel for boilers with respect to the conventionally accepted standards. The outcome of the study indicates the bagasse produced by the factory fulfills all the requirements as a boiler fuel both in quality and quantity wise, during milling time and stoppage of mill without the supply of any additional fuel. The second part of the study focuses on the steam generation and utilization unit. The study conducted in the steam generation unit shows the steam generation unit (boilers) has very low efficiency (on average 56%) when compared to the minimum accepted efficiency of boiler that uses bagasse as a fuel (70 %). The low efficiency is manifested by large quantity of heat losses that should be transferred to steam. The investigation on the steam utilization unit shows it operates without problems. In general the outcome of the study proves that the low efficiency of the boiler resulted in shortage of surplus bagasse. The research output indicates existing surplus bagasse shortage can be solved by improving the efficiency of the steam generation unit. The proposed solutions to the problems are optimization of excess air supply in the combustion chambers, application of bagasse drying system, increasing the capacity of evaporators, efficient operations, maintenance of boilers and its accessories.
Cogenerations of Energy from Sugar Factory Bagasse, American Journal of Energy Engineering.
Vol. 1, No. 2,
2013, pp. 22-29.
Meade-Chen, Sugar cane Hand book, a manual for sugar cane manufacturer and their Chemists Tenth Edition, 1997.
J.Maurice Peturau, By-Products of the cane sugar industry, an introduction to their industrial Utilization, third completely revised addition, Elsevier, Amsterdam-oxford Newyork-tokyo, 1989.
E.Hugot, Hand Book of cane sugar engineering, third com-pletely revised,edition,ELSEVIER, Amstar Dam-oxford-New York-Tokyo, 1986.
John Howard Payne, Cogeneration in the cane sugar industry, sugar series 12,Elsevier Amsterdam-oxford-New York-Tokyo, 1991
RSTCA, Regional sugar cane Training center for Africa Training Manual, Mauritius, 2001.
N.J.Themelis, P.A. Ulloa, Methane generation in landfills. Renewable Energy, 2007, 32 (7):1243–1257.
Villanueva, H. Wenzel, Paper waste – recycling, incineration or land filling, A review of existing life cycle assessments. Waste Management, 2007, 27:29–46.
R.P.Beeharry, Carbon balance of sugarcane bioenergy sys-tems. Biomass and Bioenergy, 2001, 20 (5):361–370.
W.Chaya, S.H.Gheewala, Life cycle assessment of MSW-to-energy schemes in Thailand. Journal of Cleaner Production, 2007, 15(15):1463–1468.
Eriksson, M.C. Reich, B.Frostell, A.Bjorklund, G. Assefa, J.O. Sundqvist, J.Granath, A.Baky, L.Thyselius, Municipal solid waste management from a systems perspective. Journal of Cleaner Production, 2005, 13 (3):241–252.
M.Hauschild, H. Wenzel, Environmental Assessment of Products: Scientific Background, vol. 2. Chapman and Hall, London, UK, 1998.
D.Janghathaikul, S.H. Gheewala, Environmental assessment of power generation from bagasse, 2005.
Bhattacharyya, C.Subhes, Applied general equilibrium models for energy studies: a survey" Energy Economics, 1996, 18:145–164.
Moreira, R.Jose, J. Goldemberg, The alcohol program" Energy Policy, 1999, 27:229–245.
K.Deepchand, A Note on the Pyrolysis Behaviors of Sugar Cane Fibrous Products. Biological Wastes, 2007, 20:203-208.