American Journal of Modern Energy

| Peer-Reviewed |

Study on Preparation and Electrochemical Properties of Biomass-Derived Spherical Activated Carbon

Received: 25 October 2018    Accepted: 04 December 2018    Published: 03 January 2019
Views:       Downloads:

Share This Article

Abstract

Spherical activated carbon (SPs) with hierarchical porous structure was prepared via a simple solvent evaporation method followed by an activation process using leonardite humic acid (LHA) as carbon source. The surface morphologies and pore parameters of the as-prepared SPs were analyzed by scanning electron microscope (SEM) and N2 physical adsorption-desorption instrument. The electrochemical performance of supercapacitors tested by galvanostatic charge-discharge (GCD), cyclic voltammograms (CV) and electrochemical impedance spectroscopy (EIS) are conducted in both aqueous and organic electrolyte. The SPs with high specific surface area (2034 m2 g-1) and pore volume (1.24 cm3 g-1) exhibit a superior higher specific capacitance of 319 F g-1 at a current density of 0.05 A g-1 in aqueous electrolyte compared with powdered activated carbon (SP1). In addition, SPs1 also exhibit a high initial specific capacitance of 154 F·g-1 at 0.05 A·g-1 and a higher capacitance retention of 96.4% than the bulked sample started from the same raw materials in organic electrolyte. These results suggest that the LHA-based spherical activated carbon should be a competitive and promising supercapacitor electrode material.

DOI 10.11648/j.ajme.20180404.11
Published in American Journal of Modern Energy (Volume 4, Issue 4, August 2018)
Page(s) 26-32
Creative Commons

This is an Open Access article, distributed under the terms of the Creative Commons Attribution 4.0 International License (http://creativecommons.org/licenses/by/4.0/), which permits unrestricted use, distribution and reproduction in any medium or format, provided the original work is properly cited.

Copyright

Copyright © The Author(s), 2024. Published by Science Publishing Group

Keywords

Humic Acid, Spherical Activated Carbon, Pore Structure, Supercapacitors

References
[1] Y. Guo, L. Yu, C. Y. Wang, Z. Lin, X. W. Lou, Hierarchical Tubular Structures Composed of Mn-Based Mixed Metal Oxide Nanoflakes with Enhanced Electrochemical Properties. Advanced Functional Materials 2015, 25 (32): 5184-5189.
[2] Z. B. Lei, J. T. Zhang, X. S. Zhao, Ultrathin MnO2 nanofibers grown on graphitic carbon spheres as high-performance asymmetric supercapacitor electrodes. Journal of Materials Chemistry, 2012, 22 (1): 153-160.
[3] Z. H. Hou, X. H. Li, E. H. Liu, Z. Q. He, et al. New mesoporous carbons prepared bya simultaneous synthetic template carbonization methodfor electric double layer capacitors. New carbon materials, 2004, 19 (1): 11-15.
[4] C. Merlet, B. Rotenberg, P. A. Madden, et al. On the molecular origin of supercapacitance in nanoporous carbon electrodes. Nature Materials, 2012, 11 (4): 306-310.
[5] P. Staiti, A. Arenillas, F. Lufrano, et al. High energy ultracapacitor based on carbon xerogel electrodes and sodium sulfate electrolyte. Journal of Power Sources, 2012, 214 (4): 137-141.
[6] M. Chen, C. Yu, S. H. Liu, X. Fan, X. Zhao, J. S. Qiu, Micro-sizedporous carbon spheres with ultra-high rate capability for lithium storage. Nanoscale, 2015 7: 1791–1795.
[7] X. J. He, H. B. Zhang, H. Zhang, X. J. Li, N. Xiao, J. S. Qiu, Directsynthesis of 3D hollow porous graphene balls from coal tar pitch forhigh performance supercapacitors. Journal of Materials Chemistry A, 2014, 2: 19633–19640.
[8] M. Seredych, D. Hulicova-Jurcakova, G. Q. Lu, T. J. Bandosz, Surface functional groups of carbons and the effects of their chemical character, density and accessibility to ions on electrochemical performance. Carbon, 2008, 46: 1475-1488.
[9] F. B. Li, Q. L. Qian, F. Yan, G. Q. Yuan, Nitrogen-doped porous carbon microspherules as supports for preparing monodisperse nickel nanoparticles. Carbon, 2006, 44: 128–132.
[10] Y. G. Zhang, C. Y. Wang, P. Yan, Progress in Preparation and Application of Pitch-based Spherical Activated carbon. Materials Review, 2002, 2 (16): 46-48.
[11] J. Tang, J. Liu, C. L. Li, et al. Synthesis of Nitrogen-Doped Mesoporous Carbon Spheres with Extra‐Large Pores through Assembly of Diblock Copolymer Micelles. Angewandte Chemie International Edition, 2015, 54 (2): 588-593.
[12] Y. K. Lv, L. H. Gan, M. X. Liu, W. Z. Xiong, J. Xu, D. Z. Zhu, et al. A self-template synthesis of hierarchical porous carbon foams based on banana peel for supercapacitor electrodes. Journal of Power Sources, 2012, 209: 152–157.
[13] Z. J. Qiao, M. M. Chen, C. Y. Wang, Humic acids-based hierarchical porous carbons as high-rate performance electrodes for symmetric supercapacitors. Bioresource Technology, 2014, 163: 386–389.
[14] Y. Z. Ma, B. J. Yu, Y. Guo, et al. Facile synthesis of biomass-derived hierarchical porous carbon microbeads for supercapacitors. Journal of Solid State Electrochemistry, 2016, 1-10.
[15] L. F. Chen, X. D. Zhang, H. W. Liang, M. G. Kong, Q. F. Guan, P. Chen, Z. Y. Wu, S. H. Yu, Synthesis of nitrogen-doped porous carbon nanofibers as an efficient electrode material for supercapacitors, ACS Nano, 2012, 6: 7092-7102.
[16] I. Michio, K. Hidetaka, T. Osamu, Carbon materials for electrochemicalcapacitors. Journal of Power Sources, 2010, 195 (24): 7880–7903.
[17] P. Chen, D. D. Chung, Dynamic mechanical behavior of flexible graphite made from exfoliated graphite. Carbon, 2012, 50 (1): 283-289.
[18] S. G. Hashmi, J. Halme, T. Saukkonen, E. Rautama, P. Lund, High performance low temperature carbon composite catalysts for flexible dye sensitized solar cells. Physical Chemistry Chemical Physics, 2013, 15 (40): 17689-17695.
[19] V. Ruiz, A. G. Pandolfo. High-frequency carbon supercapacitorsfrom polyfurfuryl alcohol. Journal of Power Sources, 2011, 196 (18): 7816–7822.
[20] K. Kierzek, E. Frackowiak, G. Lota, G. Gryglewicz, J. Machnikowski. Electrochemical capacitors based on highly porous carbonsprepared by KOH activation. Electrochim Acta, 2004, 49 (4): 515–23.
[21] Y. Z. Ma, Y. G, et al. Biomass-derived dendritic-like porous carbon aerogels for supercapacitors. Electrochim Acta, 2016, 210: 897-904.
[22] Z. B. Lei, N. Christov, L. L. Zhang, X. S. Zhao. Mesoporous carbon nanospheres with an excellent electro capacitive performance. Journal of Materials Chemistry 2011, 21 (7): 2274–2281.
[23] Y. M. Tan, C. F. Xu, G. X. Chen, Z. H. Liu, M. Ma, Q. J. Xie, N. F. Zheng and S. Z. Yao, Synthesis of Ultrathin Nitrogen-Doped Graphitic Carbon Nanocages as Advanced Electrode Materials for Supercapacitor. ACS Appl. Mater. Interfaces, 2013, 5, 2241–2248.
[24] H. Xu, Q. M. Gao, H. L. Guo, H. L. Wang, Hierarchical porous carbon obtained using the template of NaOH-treated zeolite b and its high performance as supercapacitor, Microporous Mesoporous Mater 2010, 133: 106-144.
[25] Y. T. Li, Y. T. Pi, L. M. Lu, S. H. Xu, T. Z. Ren, Hierarchical porous active carbon from fallen leaves by synergy of K2CO3 and their supercapacitor performance, J. Power Sources 2015, 299: 519-528.
[26] Y. Liu, Z. Wang, W. Teng, H. Zhu, J. Wang, A. A. Elzatahry, D. Y. Zhao, A template-catalyzed in situ polymerization and co-assembly strategy for rich nitrogen-doped mesoporous carbon. Journal of Materials Chemistry, 2018, 6 (7): 3162-3170.
Author Information
  • Key Laboratory for Green Chemical Technology of Ministry of Education, School of Chemical Engineering and Technology, Tianjin University, Tianjin, P. R. China; Collaborative Innovation Center of Chemical Science and Engineering (Tianjin), Tianjin, P. R. China

  • Key Laboratory for Energy Conversion and Storage Materials, College of Chemistry, Beijing Normal University, Beijing, China

  • Key Laboratory for Green Chemical Technology of Ministry of Education, School of Chemical Engineering and Technology, Tianjin University, Tianjin, P. R. China; Collaborative Innovation Center of Chemical Science and Engineering (Tianjin), Tianjin, P. R. China

  • Key Laboratory for Green Chemical Technology of Ministry of Education, School of Chemical Engineering and Technology, Tianjin University, Tianjin, P. R. China; Collaborative Innovation Center of Chemical Science and Engineering (Tianjin), Tianjin, P. R. China

  • Key Laboratory for Green Chemical Technology of Ministry of Education, School of Chemical Engineering and Technology, Tianjin University, Tianjin, P. R. China; Collaborative Innovation Center of Chemical Science and Engineering (Tianjin), Tianjin, P. R. China

Cite This Article
  • APA Style

    Yuzhu Ma, Cong Zhou, Baojun Yu, Mingming Chen, Chengyang Wang. (2019). Study on Preparation and Electrochemical Properties of Biomass-Derived Spherical Activated Carbon. American Journal of Modern Energy, 4(4), 26-32. https://doi.org/10.11648/j.ajme.20180404.11

    Copy | Download

    ACS Style

    Yuzhu Ma; Cong Zhou; Baojun Yu; Mingming Chen; Chengyang Wang. Study on Preparation and Electrochemical Properties of Biomass-Derived Spherical Activated Carbon. Am. J. Mod. Energy 2019, 4(4), 26-32. doi: 10.11648/j.ajme.20180404.11

    Copy | Download

    AMA Style

    Yuzhu Ma, Cong Zhou, Baojun Yu, Mingming Chen, Chengyang Wang. Study on Preparation and Electrochemical Properties of Biomass-Derived Spherical Activated Carbon. Am J Mod Energy. 2019;4(4):26-32. doi: 10.11648/j.ajme.20180404.11

    Copy | Download

  • @article{10.11648/j.ajme.20180404.11,
      author = {Yuzhu Ma and Cong Zhou and Baojun Yu and Mingming Chen and Chengyang Wang},
      title = {Study on Preparation and Electrochemical Properties of Biomass-Derived Spherical Activated Carbon},
      journal = {American Journal of Modern Energy},
      volume = {4},
      number = {4},
      pages = {26-32},
      doi = {10.11648/j.ajme.20180404.11},
      url = {https://doi.org/10.11648/j.ajme.20180404.11},
      eprint = {https://download.sciencepg.com/pdf/10.11648.j.ajme.20180404.11},
      abstract = {Spherical activated carbon (SPs) with hierarchical porous structure was prepared via a simple solvent evaporation method followed by an activation process using leonardite humic acid (LHA) as carbon source. The surface morphologies and pore parameters of the as-prepared SPs were analyzed by scanning electron microscope (SEM) and N2 physical adsorption-desorption instrument. The electrochemical performance of supercapacitors tested by galvanostatic charge-discharge (GCD), cyclic voltammograms (CV) and electrochemical impedance spectroscopy (EIS) are conducted in both aqueous and organic electrolyte. The SPs with high specific surface area (2034 m2 g-1) and pore volume (1.24 cm3 g-1) exhibit a superior higher specific capacitance of 319 F g-1 at a current density of 0.05 A g-1 in aqueous electrolyte compared with powdered activated carbon (SP1). In addition, SPs1 also exhibit a high initial specific capacitance of 154 F·g-1 at 0.05 A·g-1 and a higher capacitance retention of 96.4% than the bulked sample started from the same raw materials in organic electrolyte. These results suggest that the LHA-based spherical activated carbon should be a competitive and promising supercapacitor electrode material.},
     year = {2019}
    }
    

    Copy | Download

  • TY  - JOUR
    T1  - Study on Preparation and Electrochemical Properties of Biomass-Derived Spherical Activated Carbon
    AU  - Yuzhu Ma
    AU  - Cong Zhou
    AU  - Baojun Yu
    AU  - Mingming Chen
    AU  - Chengyang Wang
    Y1  - 2019/01/03
    PY  - 2019
    N1  - https://doi.org/10.11648/j.ajme.20180404.11
    DO  - 10.11648/j.ajme.20180404.11
    T2  - American Journal of Modern Energy
    JF  - American Journal of Modern Energy
    JO  - American Journal of Modern Energy
    SP  - 26
    EP  - 32
    PB  - Science Publishing Group
    SN  - 2575-3797
    UR  - https://doi.org/10.11648/j.ajme.20180404.11
    AB  - Spherical activated carbon (SPs) with hierarchical porous structure was prepared via a simple solvent evaporation method followed by an activation process using leonardite humic acid (LHA) as carbon source. The surface morphologies and pore parameters of the as-prepared SPs were analyzed by scanning electron microscope (SEM) and N2 physical adsorption-desorption instrument. The electrochemical performance of supercapacitors tested by galvanostatic charge-discharge (GCD), cyclic voltammograms (CV) and electrochemical impedance spectroscopy (EIS) are conducted in both aqueous and organic electrolyte. The SPs with high specific surface area (2034 m2 g-1) and pore volume (1.24 cm3 g-1) exhibit a superior higher specific capacitance of 319 F g-1 at a current density of 0.05 A g-1 in aqueous electrolyte compared with powdered activated carbon (SP1). In addition, SPs1 also exhibit a high initial specific capacitance of 154 F·g-1 at 0.05 A·g-1 and a higher capacitance retention of 96.4% than the bulked sample started from the same raw materials in organic electrolyte. These results suggest that the LHA-based spherical activated carbon should be a competitive and promising supercapacitor electrode material.
    VL  - 4
    IS  - 4
    ER  - 

    Copy | Download

  • Sections