American Journal of Polymer Science and Technology

| Peer-Reviewed |

The Removal of Single and Binary Basic Dyes from Synthetic Wastewater Using Bentonite Clay Adsorbent

Received: 25 September 2018    Accepted: 04 March 2019    Published: 21 March 2019
Views:       Downloads:

Share This Article

Abstract

In order to broaden the application of Bentonite clay, an easily obtainable and bio-available low cost adsorbent, it was employed for the decolourization of synthetic wastewater consisting of single and binary basic dyes (Malachite green and Rhodamine b). The adsorbent was used as obtained without any further modification and also characterized for its specific surface area, point of zero charge and its surface functional groups pre and post dyes sorption was determined using Fourier Transform Infrared Spectroscopy (FTIR). Batch adsorption methods were employed in order to study the effects of pH, Ionic strength and contact time in the single solute system. The parameters of sorption of Rhodamine B (RDB) and Malachite green (MG) were obtained and fitted to three isotherm models; Freundlich, Langmuir and Temkin. The Freundlich plot analysis indicated the process occurred via heterogeneous coverage of adsorbent by both dyes. The kinetics of adsorption data were analyzed using the; pseudo-first order, pseudo-second order, Intraparticle diffusion, film diffusion, and Boyd kinetic models. Over the study of these parameters, the film diffusion mechanism was found to predominate in the sorption process of the dyes. Competitive sorption studies were carried out by using both dyes as either the adsorbate of interest or as the interfering specie. The competitive co-coefficient values obtained from interfering MG in RDB removal were significantly lower than those obtained from interfering RDB in MG removal, indicating that the presence of RDB in the aqua matrix had antagonistic effect on MG adsorption by Bentonite.

DOI 10.11648/j.ajpst.20190501.13
Published in American Journal of Polymer Science and Technology (Volume 5, Issue 1, March 2019)
Page(s) 16-28
Creative Commons

This is an Open Access article, distributed under the terms of the Creative Commons Attribution 4.0 International License (http://creativecommons.org/licenses/by/4.0/), which permits unrestricted use, distribution and reproduction in any medium or format, provided the original work is properly cited.

Copyright

Copyright © The Author(s), 2024. Published by Science Publishing Group

Keywords

Freundlich, Langmuir, Temkin, Adsorption, Malachite Green, Bentonite

References
[1] Banat IM, Nigam P, Mc Mullan G, Marchant R, Singh D (1996). Microbial decolourization of textile dye containing effluents. Bioresource Technology 58, 217-227.
[2] McKay, G; Porter, J. F; Prasad, G. R. (1999). The removal of dye colours from aqueous solutions by adsorption on low-cost materials, Water, Air, Soil Pollution. 114, 423–438.
[3] McMullan, G.; Meehan, C.; Conneely, A.; Nirby, N.; Robinson, P.; Nigam, I.; Bannat, M. and Marchant, S. W. F. (2001). Mini-review: Microbial decolorization and degradation of textile dyes. Appl. Microbiol. Biotechnol., 56, 81 – 87.
[4] Goldberg, S. (2005). Equations and Models describing Adsorption Processes in Soils. Chemical Processes in Soils, Soil Science Society of America (SSSA). SSSA, Wisconsin. p 489.
[5] Derbyshire, F., Jagtoyen, M., Andrew, R., Rao, A., Martin-Gullon, I., Grulke, E., (2001) Carbon Materials in Environmental Applications, In: Radovic, L. R. (Ed.), Chemistry and Physics of Carbon, 27, Marcel Dekker, New York, 1 – 66.
[6] Ho YS, Mckay G (2003). Sorption of dyes and copper ions onto biosorbents, Proc. Biochem. 38: 1047-1061.
[7] Jain, A. K., Gupta, V. K., Bhatnagar, A. S. (2003) Utilization of industrial waste products as adsorbents for the removal of dyes. J. Hazard. Mater., B, 101, 31-42.
[8] Gupta, V. K.; Suhas. (2009). Application of low-cost adsorbents for dye removal—A review. J. Environ. Manag. 2009, 90, 2313–2342.
[9] Tahir, H.; Hammed, U.; Sultan, M.; Jahanzeb, Q. (2010). Batch adsorption technique for the removal of malachite green and fast green dyes by using montmorillonite clay as adsorbent. Afr. J. Biotechnol, 9, 8206–8214.
[10] Balistrieri, L. S. and Muray, J. W. (1981). The surface chemistry of Geothile (αFeooH) in major ion sea water. American Journal of Science, 281, 788-806.
[11] Sears G. W (1956) Determination of Specific Surface Area of Colloidal Silica by Titration with Sodium Hydroxide Anal. Chem. 28, 1981–1983.
[12] Nidheesh, P. V., Gandhimathi, R., Ramesh, S. T. and Singh, T. S. A. (2012). Adsorption and Desorption Characteristics of Crystal Violet in Bottom Ash Column. Journal of Urban and Environmental Engineering, 6(1): 18-29.
[13] Olaseni S. E., Oladoja N. A., Owoyomi O., Aboluwoye C. O., and Osundiya M. O (2014). Adsorption of Brilliant Green onto Luffa Cylindrical Sponge: Equilibrium, Kinetics, and Thermodynamic Studies. ISRN Physical Chemistry.
[14] Sheindorf, Ch. Rebhun, M. and Sheintuch, M., (1981) . A Freundlich-type multicomponent isotherm, J. Colloid and Interface Sci., 79, 136-142.
[15] Oladoja N. A., Akinlabi A. K., (2009). Congo Red Biosorption on palm kernel seed coat. Industrial and Engineering Chemistry Research, 48, 6188-6196.
[16] Nomanbhay MS, Palanisamy K. (2005) Removal of heavy metal from industrial waste using chitosan coated oil palm shell charcoal. Elect. J. Biotechnol, 8, 43-53.
[17] Hashen F. S. (2012) Adsorption of Methylene Blue from aqueous solutions using Fe3O4/Bentonite nanocomposite. Hydrol Current Res 3: 143- 148.
[18] Akpomie K. G, Dawodu F. A (2015) Potential of a low-cost bentonite for heavy metal abstraction from binary component system. Beni-suef university journal of basic and applied sciences 4, 1 -13.
[19] Lanregren, S. (1889) “About the theory of so-called adsorption of soluble substances,” Kungliga Svenska Vetenskapsakademiens Handlingar, 24, 1–39,
[20] Ho, Y. S. (2004). Citation Review of Lagergren kinetic rate equation on adsorption reactions. Scientometrics 59, 171–177.
[21] Muhammad K. D., Linda B. L. (2016). The removal of Rhodamine B dye from aqueous solution using Casuarina Equisefolia Needles (CEN) as adsorbent. Journal Cogent Environmental Science 2, 1-14.
[22] Muhammad K. D., Linda B. L. Lim. (2015). Application of Casuarina Equisefolia Needles (CEN) for the removal of methylene blue and malachite green dyes from aqueous solution. Alexandria Engineering Journal 54, 2015, 1253-1263.
[23] Weber Jr., W. J., Morris, J. C. and Sanit, J. (1963) Kinetics of Adsorption on Carbon from Solution. Journal of the Sanitary Engineering Division, American Society of Civil Engineers, 89, 31-38.
[24] Kannan N. and Sundaram M. M (2001). Kinetics and mechanism of removal of methylene blue by adsorption on various carbons—a comparative study, Dyes and Pigments, 51, 25–40.
[25] Poots, V. J. P.; McKay, G.; Healy, J. J. (1978) Removal of basic dye from effluent using wood as an adsorbent. J. Water Pollut. Control Fed. 50, 926–939.
[26] Lakshmi, U. R., Srivastava, V. C, Mall, I. D, Lataye, D. H. (2009) Rice husk ash as an effective adsorbent: evaluation of adsorptive characteristics for indigo carmine dye, Journal of Environmental Management, 90, 710–720.
[27] Boyd G. E., Adamson A. W., Myers Jr L. S (1947). The exchange adsorption of ions from aqueous solutions by organic zeolites. II. Kinetics J Am Chem Soc, 69, 2836–2848.
[28] Alshabanat, M. Alsenani, G. and Almufarij, R. (2013). Removal of Crystal Violet Dye from Aqueous Solutions onto Date Palm Fiber by Adsorption Technique. Journal of Chemistry, Volume 2013, Article ID 210239, 1-6.
[29] Freundlich, H. (1906). Ueber die Adsorption in Loesungen. Zeitschrift Fur Physikalische Chemie-Stochiometrie Und Verwandtschaftslehre, 57, 385-470.
[30] Runping, H., Pan, H., Zhaohui, C., Zhenhui, Z., and Mingsheng, T. (2008). Kinetics and isotherms of Neutral Red adsorption on peanut husk. Journal of Environmental Sciences, 20: 1035–1041.
[31] Rahman M. A., Ruhul A. S. M. & Shafiqul A. A. M. (2012). Removal of Methylene Blue from Waste Water using Activated Carbon prepared fromRice Husk. Dhaka University Journal of Science, 60, 185-189.
[32] [32]Temkin, M. and Pyzhev, V. (1940) Kinetics of Ammonia Synthesis on Promoted Iron Catalysts. Acta Physicochimica URSS, 12, 217-222.
[33] Nandi B. K., Goswami A. Purkait M. K (2009) Adsorption characteristics of brilliant green dye on kaolin, Journal of Hazardous Materials, 161, 387–395.
[34] Hu, Y., Gou, T., Ye, X., Li, Q., Gou, M., Liu, H., and Wu, Z. (2013). Dye adsorption by resins: effect of ionic strength on hydrophobic and electrostatic interaction. Chemical Engineering Journal, 228, 392-397
[35] Mercer K. L, Tobiason J. E. (2008). Removal of arsenic from high ionic strength solutions: effects of ionic strength, pH, and preformed versus in situ formed HFO, Environ. Sci. Technol. 42, 3797–3802.
[36] Piret F. Su B.-L. (2008) Effects of pH and ionic strength on the self-assembly of silica colloids to opaline photonic structures, Chem. Phys. Lett. 457, 376–380.
[37] Deb D. L, Datta N. P (1967). Effect of associating anions on phosphorus retention in soil, Plant Soil. 26, 303–316.
[38] Wu C.-H, Kuo, C.-Y. Lin, C.-F, Lo, S.-F. (2002) Modeling competitive adsorption of molybdate, sulfate, selenate, and selenite using a Freundlich-type multi- component isotherm, Chemosphere 47, 283–292.
[39] Oladoja, N. A., Hu, S., Drewes, J. E., Helbreich, B. (2016). Insight into defluoridation efficiency of nano magnesium oxide in groundwater system contaminated with hexavalent chromium and fluoride. Separation and Purification Technology 162, 195–202.
Author Information
  • Department of Chemical Sciences, Adekunle Ajasin University, Akungba-Akoko, Nigeria

  • Department of Chemical Sciences, Adekunle Ajasin University, Akungba-Akoko, Nigeria

  • Department of Chemical Sciences, Adekunle Ajasin University, Akungba-Akoko, Nigeria

Cite This Article
  • APA Style

    Olaseni Segun Esan, Akeremale Olaniran Kolawole, Aboluwoye Christopher Olumuyiwa. (2019). The Removal of Single and Binary Basic Dyes from Synthetic Wastewater Using Bentonite Clay Adsorbent. American Journal of Polymer Science and Technology, 5(1), 16-28. https://doi.org/10.11648/j.ajpst.20190501.13

    Copy | Download

    ACS Style

    Olaseni Segun Esan; Akeremale Olaniran Kolawole; Aboluwoye Christopher Olumuyiwa. The Removal of Single and Binary Basic Dyes from Synthetic Wastewater Using Bentonite Clay Adsorbent. Am. J. Polym. Sci. Technol. 2019, 5(1), 16-28. doi: 10.11648/j.ajpst.20190501.13

    Copy | Download

    AMA Style

    Olaseni Segun Esan, Akeremale Olaniran Kolawole, Aboluwoye Christopher Olumuyiwa. The Removal of Single and Binary Basic Dyes from Synthetic Wastewater Using Bentonite Clay Adsorbent. Am J Polym Sci Technol. 2019;5(1):16-28. doi: 10.11648/j.ajpst.20190501.13

    Copy | Download

  • @article{10.11648/j.ajpst.20190501.13,
      author = {Olaseni Segun Esan and Akeremale Olaniran Kolawole and Aboluwoye Christopher Olumuyiwa},
      title = {The Removal of Single and Binary Basic Dyes from Synthetic Wastewater Using Bentonite Clay Adsorbent},
      journal = {American Journal of Polymer Science and Technology},
      volume = {5},
      number = {1},
      pages = {16-28},
      doi = {10.11648/j.ajpst.20190501.13},
      url = {https://doi.org/10.11648/j.ajpst.20190501.13},
      eprint = {https://download.sciencepg.com/pdf/10.11648.j.ajpst.20190501.13},
      abstract = {In order to broaden the application of Bentonite clay, an easily obtainable and bio-available low cost adsorbent, it was employed for the decolourization of synthetic wastewater consisting of single and binary basic dyes (Malachite green and Rhodamine b). The adsorbent was used as obtained without any further modification and also characterized for its specific surface area, point of zero charge and its surface functional groups pre and post dyes sorption was determined using Fourier Transform Infrared Spectroscopy (FTIR). Batch adsorption methods were employed in order to study the effects of pH, Ionic strength and contact time in the single solute system. The parameters of sorption of Rhodamine B (RDB) and Malachite green (MG) were obtained and fitted to three isotherm models; Freundlich, Langmuir and Temkin. The Freundlich plot analysis indicated the process occurred via heterogeneous coverage of adsorbent by both dyes. The kinetics of adsorption data were analyzed using the; pseudo-first order, pseudo-second order, Intraparticle diffusion, film diffusion, and Boyd kinetic models. Over the study of these parameters, the film diffusion mechanism was found to predominate in the sorption process of the dyes. Competitive sorption studies were carried out by using both dyes as either the adsorbate of interest or as the interfering specie. The competitive co-coefficient values obtained from interfering MG in RDB removal were significantly lower than those obtained from interfering RDB in MG removal, indicating that the presence of RDB in the aqua matrix had antagonistic effect on MG adsorption by Bentonite.},
     year = {2019}
    }
    

    Copy | Download

  • TY  - JOUR
    T1  - The Removal of Single and Binary Basic Dyes from Synthetic Wastewater Using Bentonite Clay Adsorbent
    AU  - Olaseni Segun Esan
    AU  - Akeremale Olaniran Kolawole
    AU  - Aboluwoye Christopher Olumuyiwa
    Y1  - 2019/03/21
    PY  - 2019
    N1  - https://doi.org/10.11648/j.ajpst.20190501.13
    DO  - 10.11648/j.ajpst.20190501.13
    T2  - American Journal of Polymer Science and Technology
    JF  - American Journal of Polymer Science and Technology
    JO  - American Journal of Polymer Science and Technology
    SP  - 16
    EP  - 28
    PB  - Science Publishing Group
    SN  - 2575-5986
    UR  - https://doi.org/10.11648/j.ajpst.20190501.13
    AB  - In order to broaden the application of Bentonite clay, an easily obtainable and bio-available low cost adsorbent, it was employed for the decolourization of synthetic wastewater consisting of single and binary basic dyes (Malachite green and Rhodamine b). The adsorbent was used as obtained without any further modification and also characterized for its specific surface area, point of zero charge and its surface functional groups pre and post dyes sorption was determined using Fourier Transform Infrared Spectroscopy (FTIR). Batch adsorption methods were employed in order to study the effects of pH, Ionic strength and contact time in the single solute system. The parameters of sorption of Rhodamine B (RDB) and Malachite green (MG) were obtained and fitted to three isotherm models; Freundlich, Langmuir and Temkin. The Freundlich plot analysis indicated the process occurred via heterogeneous coverage of adsorbent by both dyes. The kinetics of adsorption data were analyzed using the; pseudo-first order, pseudo-second order, Intraparticle diffusion, film diffusion, and Boyd kinetic models. Over the study of these parameters, the film diffusion mechanism was found to predominate in the sorption process of the dyes. Competitive sorption studies were carried out by using both dyes as either the adsorbate of interest or as the interfering specie. The competitive co-coefficient values obtained from interfering MG in RDB removal were significantly lower than those obtained from interfering RDB in MG removal, indicating that the presence of RDB in the aqua matrix had antagonistic effect on MG adsorption by Bentonite.
    VL  - 5
    IS  - 1
    ER  - 

    Copy | Download

  • Sections